365B Electrical System
365B:
9PZ234-UP
9TZ325-UP
©
2000 Caterpillar
All Rights Reserved
Printed in U.S.A.
Failure Mode Identifiers (FMI)¹
FMI No.
Failure Description
0 Data valid but above normal operational range.
1 Data valid but below normal operational range.
2 Data erratic, intermittent, or incorrect.
3 Voltage above normal or shorted high.
4 Voltage below normal or shorted low.
5 Current below normal or open circuit.
6 Current above normal or grounded circuit.
7 Mechanical system not responding properly.
8 Abnormal frequency, pulse width, or period.
9 Abnormal update.
10 Abnormal rate of change.
11 Failure mode not identifiable.
12 Bad device or component.
13 Out of calibration.
14 Parameter failures.
15 Parameter failures.
16 Parameter not available.
17 Module not responding.
18 Sensor supply fault.
19 Condition not met.
20 Parameter failures.
¹The FMI is a diagnostic code that indicates what type of failure has occurred.
Related Electrical Service Manuals
Form Number
Alternator: 132-2156
SENR4757
(VIDS) Vital Information Display System: 142-5076
RENR3102
3196 Troubleshooting Guide: 115-3055
RENR1283
Machine Control: 151-2099
RENR3103
Title
A AA
1
2
325-PK-14
200-BK-14
T
This indicates that the component does not have a wire connected to ground. It is
grounded by being fastened to the machine.
This indicates that the component has a wire connected to it that is connected to ground.
105-9344
T
Normally open switch that will close with an increase of a specificcondition (temp-press-etc.).
The circle indicates that the componenthas screw terminals and a wire can be disconnected from it.
Pin
Socket
Fuse
Component
Part Number
Pin or Socket
Number
Receptacle
Plug
Wire Gauge
Wire, Cable, or Harness
Assembly Identification
Wire Color
Normally closed switch that will open with an increase of a specific condition.
No circle indicates that the wire cannot be disconnected from the component.
Single Wire
Connector
Circuit Number
Identification
Ground
Connection
Pressure
Symbol
Temperature
Symbol
Level
Symbol
Flow
Symbol
Circuit Breaker
Symbol
Reed Switch - A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Sender- A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.
Relay (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.
Solenoid - A solenoid is an electrical component that is activated by electricity. It has a
coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.
Harness And Wire Symbols
Electrical Schematic Symbols And Definitions
1
1
2
2
Typical representation of a Sure-Seal
connector. The plug and receptacle
contain both pins and sockets.
Typical representation of a Deutsch
connector. The plug contains all
sockets and the receptacle contains
all pins.
Wire
Number
Wire
Color
Description
Wire
Number
Wire
Color
Description
101 RD Bat (+) A745 WH Fuel Pressure
103 RD Dome Lamp A706 GY Injector #6
105 RD Key Sw A746 PK Turbo Outlet Pressure (Pin 23)¹
109 RD Alt Output (+) Term. A747 GY Atmospheric Pressure (Pin 20)¹
110 RD Timer Relay A751 YL After Cooler Temp (Pin 15)¹
112 PU Main Relay Resistor to Breaker 3 A755 PK Throttle SW #1
113 OR Spare A756 BU Throttle SW #2
114 RD Warning Horn A757 GY Throttle SW #3
115 RD Chassis Lamp A758 BR Throttle SW #4
118 GY Washer/Wiper A768 BU Pump Control Valve #1 (+)
120 YL 12V 5A Socket L983 WH Injector Common 1 & 2
124 GN A/C Heater L984 OR Injector Common 3 & 4
129 BU Cigar Lighter L985 YL Injector Common 5 & 6
130 RD Bat (+) E707 GN VIMS Display +V
131 RD Bat (+) E708 PK VIMS Display Clock
133 RD Bat (+) E720 GN Data Link (-) J1922
135 BU Bat (+) E789 PU HEX Machine Cntl Sol Return #1
139 OR Bat (+) E790 PK HEX Machine Cntl Sol Return #2
140 BU Lubricator E793 BU ATA Data Link - (Pin 1)¹
147 PU CWTW Removal E794 YL ATA Data Link + (Pin 7)¹
148 RD Boom Lamp E799 BR Jake Sol Driver Common
149 RD Boom Lamp F700 BU Jake Sol Driver
150 RD Bat (+) F701 BR Jake Sol Driver
151 GN Hyd Lock Solenoid F717 YL SW 4 (App Specific) (Pin 14)¹
152 BU Aux Ckt F718 BU SW 5 (App Specific) (Pin 20)¹
154 RD Neutral Start Relay H716 WH Impl Cont Sol Return
160 RD Cab Lamp F732 PK Eng Speed/Timing +V
168 RD ATT Refuel Breaker Ckt H733 BU Hex Backup Pump Resistor To Diode
170 YL Power Relay 1 Ckt 801 PK Auto Lube Sol Or Motor
171 GN Power Relay 2 Ckt 892 BR VIMS Start Mod Right (-) Port/CAT Data Link (-)
175 PK Condenser Fan Relay 893 GN VIMS Start Mod Right (+) Port/CAT Data Link (+)
175 RD Fan 8630 BU Beacon Ckt
176 OR ATCH Aux Ckt F853 BR Travel Speed
177 RD Bat (+) F859 GY Backup Resistor
178 RD Bat (+) F889 WH Throttle Position Feedback
180 GN Aux Ckt H807 YL On/Off Driver Return (1-8)
185 YL SW Panel 994 GY Oil Pressure (Filtered)
196 BU Insp Lamp 995 BU Coolant Temperature
N940 BU +5V 996 GN Engine Speed/Timing Sensor Power
N941 YL Sensor Common
200 BK Main Chassis Gnd N944 PU Eng Speed/Timing Common
210 BK (24/12 Volt) Converter Output Gnd 998 BR Digital Sensor Return (Pin 29)¹
235 BK Machine Control Gnd 999 WH Primary Camshaft Speed/Timing (Pin 38)¹
C967 BU Inlet Air Temperature
304 WH Starter Relay No. 1 Output E996 WH +5V Analog (Hyd Oil Temp)
306 GN Starter Relay Coil E997 BR Hydraulic Lock
307 OR Anti Theft Relay E997 YL Action Alarm
308 YL VIDS Key Sw/Timer Relay/Power Relay 5 E998 BR Action Lamp
310 PU Start Aid SW To Start Aid Sol E998 YL Radiator Fan Solenoid
317 YL Start Aid Sol To Temp SW K907 BU Swing Brake Sol - +B
320 RD Horn Relay Coil To SW K909 BU Backup SW - +B
321 BR Travel Alarm K924 YL Safety Lock Solenoid -
322 GY Backup Alarm Lamp Travel Alarm K927 BU Solenoid Return 1
323 WH ATCH Refueling Pump K928 GN Stick Sol Retract
325 PK Fuel Pump Relay Cut-Out K929 GN Bucket Sol Retract
329 YL Fuel Pump To SW K930 GN Swing Sol Extend
332 BU Shutdown SW To Shutdown Ctrl K931 GN Bucket Sol Extend
365 YL Fuel Pump Relay To Switch K932 BU Swing Sol Left
386 PK Air Shutoff Solenoid Enable K934 BR Swing Sol Right
K943
OR Travel Left Sol Rear
403 GN Alternator (R) Term.
K944
YL Travel Left Sol Front
410 WH Opr Mon Fault Alarm
K945
GY Resistor To Left Backup SW
411 PK Opr Mon Master
K946
OR Travel Right Sol Rear
412 BU Opr Mon Cool Flow/Ds2 App Spec)(Pin 26)¹
K947
YL Travel Right Sol Front
430 BU Opr Mon Air Filter
K948
GY Resistor To Right Backup SW
491 PK VIMS Hyd Oil Temp Sensor
K949
OR Boom Retract Sol
495 GN VIMS Fuel Level Signal
K950
YL Boom Extend Sol
496 WH Opr Mon Panel Hyd Oil Level
K951
GY Resistor To Boom Backup SW
C413 YL VIMS Display Data
K952
BR Sol Return 3
C414 BU VIMS Display Load
L972
BU Low Idle SW
C415 WH VIMS Display Keydata
L976
GN Excavator Fuel Pump Switch
C468 BU Engine Oil Level
L982
PK Counterweight Removal Control Solenoid
C472 GN Front Pump Pressure
M933
PU Swing Sol Return
E455 BR Hydraulic Oil Filter
M935
BU PS Press Sol to Backup Resistor
E456 WH Autolube Pressure
M936
BR
Flow Control SW to ABL
G426 WH Swing Pressure
M937
GN
Flow Control Prox SW#1 to ABL
H441 GN Stick Lube Pressure
M938
GY
Flow Control Prox SW#2 to ABL
H442 YL Boom Lube Pressure
M941
GY
Suction Shutoff
H443 BR Swing Lube Pressure
M942
WH
Lever Top SW (LH-R)
H446 PK Boom Lower Check Pressure Sensor
M943
YL
Lever Top SW (LH-L)
H447 YL Stick Lower Check Pressure Sensor
M944
BU
Lever Top SW (RH-R)
M945
BR
Lever Top SW (RH-L)
500 BR Wiper - Front (Park)
M946
GN
Hammer 2 Selector SW
501 GN Wiper - Front (Low)
M947
OR
LH Joystick(HEDC)
506 PU Washer - Front
M948
BR
LH Joystick(HEDC)
508 PU Radio Speaker - Left
M949
PK
LH Joystick(HEDC)
509 WH Radio Speaker - Left (Common)
M950
PU
LH Joystick(HEDC)
511 BR Radio Speaker - Right
M951
WH
LH Joystick(HEDC)
512 GN Radio Speaker - Right (Common)
M952
YL
LH Joystick(HEDC)
513 OR A/C Compressor/Refrigerant Pressure SW
M953
BR
LH Joystick(HEDC)
514 PU A/C Condenser Motor
M953
BU
LH Joystick(HEDC)
521 YL A/C SW To Refrigerant SW
M954
BU
Hammer Pedal(HEDC)
524 BU Wiper - Left (Low)
M955
BR
Hammer Pedal(HEDC)
530 OR Washer Right
M956
GN
Travel Pedal(HEDC)
559 YL Auto Lube Sol
M957
GY
Travel Pedal(HEDC)
576 PK Wiper - Aux (Low)
M958
OR
Travel Pedal(HEDC)
578 BU Washer - Aux
M959
PK
Travel Pedal(HEDC)
586 BR OLWD Cancel
M960
PU
Straight Travel Pedal(HEDC)
590
GY
Wiper SW To Intermittent Module
M961
WH
Straight travel Pedal(HEDC)
593
GN
Condenser Fan Relay To Motors
M962
YL
RH Joystick(HEDC)
A537
PK
Seat Heater (Resistive Element In Cushion)
M963
BU
RH Joystick(HEDC)
A586
OR
Wiper SW To Wiper Cont
M964
BR
RH Joystick(HEDC)
C537
GN
A/C Photo Sensor + Sig
M965
GN
RH Joystick(HEDC)
C538
OR
A/C Photo Sensor - Sig
P943
GN
Stick Lowering Sol
P944
GY
Boom Lowering Sol
607
PK
Flood Lamp - Front
P945
OR
Anti Drift Sol- Stick
615
YL
Cab Flood Lamp/Rops
P946
BR
Anti Drift Sol- Boom
616
BU
Bucket Flood Lamp/Boom Flood Lamp
P949
PU
Sys Press up Sol- Front
633
BU
Attach Lighting Ckt
P950
YL
Sys Press up Sol- Rear
638
WH
Rotary Beacon
P955
BU
Hammer/Shears Selector Sol
P957
BR
ATT Extend Sol
709 OR Sensor Power Supply
P958
PK
ATT Retract Sol
786 RD Eng Speed Cont - Hi Press SW
P959
GN
Switch Panel(HEDC)
788 YL Eng Speed (+)
P964
GY
Switch Panel(HEDC)
791 RD Eng Speed Cont - Lo Sol
P965
OR
Switch Panel(HEDC)
A701 GY Injector #1
P966
PK
Switch Panel(HEDC)
A702 PU Injector #2
P967
PU
Digital Return(HEDC)
A703 BR Injector #3
P968
OR
Capsule Filter Plugging SW
A704 GN Injector #4
P969
BR
Analog Return(HEDC)
A705 BU Injector #5
¹ MEUI -ADEMII
Wire Description
Lighting Circuits
Control Circuits
Power Circuits
Accessory Circuits
Ground Circuits
Basic Machine Circuits
Monitoring Circuits
Control Circuits (Continued)
Resistor, Sender and Solenoid Specifications
Part No. Component Description Resistance (Ohms)¹
3E-6322 Solenoid: Start Aid 6
102-8017 Resistor:
Main Relay 8dà4Þ0à r"PÝØÝ"|åÈå02CV
Back up
52 ± 2.6
111-9916 Solenoid:
Lowering Check Boom
Lowering Check Stick
PS Press
Swing Pump Swash
11.7±2.2
112-5874 Solenoid:
Att Extend
Att Retract
Boom Retract
Bucket Extend
Bucket Retract
Stick Retract
Travel LH Front
Travel LH Rear
Travel RH Front
Travel RH Rear
Stick Extend
Boom Extend
Swing LH
Swing RH
6.5 ± 0.4
121-1491
Solenoid:
Hyd Lock
Swing Brake
Travel Speed Shift
32 ± 3.2
147-5826 Solenoid:
Radiator Fan Speed Cont
Anti Drift Boom
Anti Drift Stick
Neutral Flow Bypass
System Press UP - F
System Press UP - R
34.3 ± 1.7
147-6776 Solenoid:
System Press UP - F
System Press UP - R
34.3 ± 1.7
151-9360
Resistor:
TR LH Backup
TR RH Backup
10.7 ± 0.5
155-4066
Solenoid: Injector 1 thru 6
1.06 ± 0.05
¹ At room temperature unless otherwise noted.
Connector Location
Connector Number
Schematic
Location
Machine
Location
CONN 1 C-12 D
CONN 2 C-12 D
CONN 3 F-12 33
CONN 4 F-12 34
CONN 5 F-12 34
CONN 6 C-11 D
CONN 7 C-11 D
CONN 8 C-11 D
CONN 9 A-11 E
CONN 10 A-11 35
CONN 11 B-10 6
CONN 12 G-10 36
CONN 13 H-10 36
CONN 14 H-10 36
CONN 15 I-9 D
CONN 16 I-9 D
CONN 17 H-9 D
CONN 18 H-9 D
CONN 19 G-9 D
CONN 20 G-9 D
CONN 21 B-8 F
CONN 22 B-8 F
CONN 23 B-8 F
CONN 24 B-8 F
CONN 25 H-6 37
CONN 26 H-6 32
CONN 27 H-6 G
CONN 28 H-5 G
CONN 29 H-5 G
CONN 30 H-5 G
CONN 31 F-5 G
CONN 32 F-5 G
CONN 33 F-5 G
CONN 34 C-5 A
CONN 35 C-5 A
CONN 36 C-5 A
CONN 37 C-5 A
CONN 38 B-5 38
CONN 39 B-5 39
CONN 40 B-5 A
CONN 41 A-4 40
CONN 42 F-4 G
CONN 43 F-4 G
CONN 44 F-4 G
CONN 45 H-4 G
CONN 46 H-4 G
CONN 47 H-4 G
CONN 48 H-4 G
CONN 49 H-4 42
CONN 50 H-3 G
CONN 51 H-3 A
CONN 52 A-3 39
CONN 53 A-3 43
CONN 54 A-3 35
CONN 55 A-2 35
The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near the
component. See the Component Location Chart.
Component Location
Component
Schematic
Location
Machine
Location
Component
Schematic
Location
Machine
Location
Alarm - Action C-3
A
Relay - Condenser Fan I-5
D
Alternator H-11
2
Relay - Ether H-7
D
ATCH Alarm - Travel B-6
1
Relay - Horn H-7
D
ATCH - AM/FM Radio I-3
A
Relay - Hyd Lock Sol H-7
D
ATCH - Antenna I-6
13
Relay - Main H-7
D
ATCH - Auto Lubrication Pump A-5
11
Relay - Neutral Start H-7
D
ATCH - Refueling Pump A-2
25
Relay - Suction Line Shutoff G-7
D
ATCH - Seat with Seat Heater F-3
A
Relay - Timer I-7
D
ATCH Aux - Circuit (2) G-10
B
Resister - Backup H-7
D
ATCH Battery I-12
3
Resister - Backup (TR LH) G-7
D
ATCH Breaker - Refuel I-8
D
Resister - Backup (TR RH) G-7
D
ATCH Relay - Beacon G-10
D
Resister - Main Relay H-7
D
ATCH Relay - Refueling Power A-2
12
Sender - Hyd Oil Temp A-10
13
ATCH Relay - Refueling Start A-2
12
Sensor - A/C Photo C-2
A
ATCH Relay - Refueling Stop A-2
12
Sensor - ATM Pressure E-11
H
ATCH Sensor - O.L.W.D Press Boom A-6
44
Sensor - Backup/Timing F-11
H
ATCH Solenoid - CWTW Removal Cont B-10
18
Sensor - Coolant Temp E-11
H
ATCH Solenoid - Extend A-7
F
Sensor - Eng Oil Pressure E-11
H
ATCH Solenoid - Lowering Check Boom A-7
F
Sensor - Fuel Level A-6
14
ATCH Solenoid - Lowering Check Stick A-7
F
Sensor - Fuel Pressure E-11
H
ATCH Solenoid - Retract A-9
F
Sensor - Fuel Temp D-11
H
ATCH Solenoid - Start Aid I-12
20
Sensor - Inlet Air Temp E-11
H
ATCH Speaker Left B-2
A
Sensor - Inlet Manf Pressure E-11
H
ATCH Speaker Right B-2
A
Sensor - Prim Speed/Timing F-11
H
ATCH Switch - Aux CKT (2) D-2
G
Sensor - Pump Press A-12
15
ATCH Switch - CWTW Removal B-10
29
Sensor - Swing Pump Press A-12
17
ATCH Switch - Flow Cont D-3
B
Service Meter C-2
A
ATCH Switch - Flow Cont Proximity 1 B-7
22
Socket - 12V B-3
A
ATCH Switch - Flow Cont Proximity 2 B-7
23
Solenoid - Anti Drift Boom A-9
F
ATCH Switch - OLWD Cancel D-4
G
Solenoid - Anti Drift Stick B-7
F
ATCH Switch - Refueling Level A-4
30
Solenoid - Boom Extend A-7
F
ATCH Switch - Refueling Pump (NC) A-3
7
Solenoid - Boom Retract A-9 F
ATCH Switch - Refueling Pump (NO) A-2
7
Solenoid - Bucket Extend A-7
F
ATCH Switch - Seat Heater D-3
B
Solenoid - Bucket Retract A-9
F
ATCH Switch - Start Aid D-4
B
Solenoid - Compressor GP H-12
H
ATCH Switch - Suction Line Shutoff Limit A-11
31
Solenoid - Hyd Lock A-9
F
Battery I-12
3
Solenoid - Injector 1-6 D-11 H
Breaker - Bat 1 I-8
D
Solenoid - Neutral Flow Bypass A-9
F
Breaker - Bat 2 I-8
D
Solenoid - PS Press A-9
F
Breaker 1 I-8
D
Solenoid - Radiator Fan Speed Cont A-12
19
Breaker 2 I-8
D
Solenoid - Stick Extend A-7
F
Breaker 3 I-8
D
Solenoid - Stick Retract A-9 F
Breaker 4 I-8
D
Solenoid - Swing Brake B-6
F
Breaker 5 I-8
D
Solenoid - Swing LH A-6
F
Breaker 6 I-8
D
solenoid - Swing Pump Swash A-12
17
Cigar Lighter B-2
A
Solenoid - Swing RH B-6
F
Condenser - A/C H-12
H
Solenoid - System Press Up-F A-7
F
Control - GP H-6
32
Solenoid - System Press Up-R A-7
F
Controller Engine E-12
H
Solenoid - Travel LH Front A-7
F
Converter B-2
4
Solenoid - Travel LH Rear B-9 F
Diode (2) G-8
D
Solenoid - Travel RH Front A-7
F
Diode (3) H-8
D
Solenoid - Travel RH Rear B-9 F
Fuse - Base I-5
C
Solenoid - Travel Speed Shift A-9
F
Gage - Cluster C-3
A
Switch - Air Cleaner I-12
24
Ground - Strap G-11
H
Switch - Autolub Piston Bucket A-3
25
Ground - Strap I-10
D
Switch - Autolub Piston Stick A-3
26
Ground - Relay Panel G-9 D Switch - Autolub Piston Swing A-6
27
Ground - Strap E-6
G
Switch - Backup (Boom) D-5
B
Horn (3) A-4
G
Switch - Backup (Travel Left) D-5
B
Injectors D-11
H
Switch - Backup (Travel Right) D-5
B
Joystick - LH I-2
C
Switch - Control F-2
B
Joystick - RH F-2
B
Switch - Control I-2
C
Key Pad C-3
A
Switch - Coolant Level H-12
28
Lamp - Action C-3
A
Switch - Disconnect I-9 D
Lamp - Dome B-2
A
Switch - Engine Oil Level G-12
41
Message Center B-3
A
Switch - Hyd Oil Filter A-10
E
Motor - Lower Wiper H-1
G
Switch - Hyd Oil Filter (2) A-10
E
Motor - Starter G-11
9
Switch - Hyd Oil Level A-10
E
Motor - Upper Wiper B-2
A
Switch - Key F-2
B
Motor - Washer H-11
10
Switch - Main Backup D-6
B
Pedal - Hammer G-1
G
Switch - Neutral Start Limit I-2
C
Pedal - Straight Travel G-1
G
Switch - Oil Filter Reset B-10
E
Pedal - Travel G-1
G
Switch - Panel E-2
B
Pickup - Eng Speed G-12
16
Switch - Refrigerant Low Press G-12
H
Relay - Auto Lub H-7
D
Switch - Throttle Pos E-2
31
Relay - Boom Lamp H-7
D
Switch - Windshield C-2
43
Relay - Cab Lamp G-7
D
Wiper Cont C-2
A
Relay - Chassis Lamp G-7
D
Machine locations are repeated for components located close together.
A = Located inside of cab.
B = Located inside of right console.
C = Located inside of left console.
D = Located around relay panel.
E = Located around hydraulic oil tank.
F = Located around pilot manifold.
G =Located under platform.
H = Located on or around Engine
CID
Component
0374 Swing Brake Solenoid
0376 Travel Alarm
0466 Left Travel Pedal
0467 Right Travel Pedal
0598 Travel Speed Solenoid
0790 Swing Pump (Outlet) Pressure Sensor
0864
Variable Implement Pump Oil Pressure Sensor
1118 Neutral Flow Solenoid
1119 Boom Anti Drift Solenoid
1120 Stick Anti Drift Solenoid
1121 Front System High Pressure Solenoid
1122 Rear System High Pressure Solenoid
1123 Hammer Speed Select Solenoid
1124 Anti Thft Solenoid
1125 Left Hand Lever Forward/Backward Position Sensor
1126 Left Hand Lever Left/Right Position Sensor
1127 Right Hand Lever Forward/Backward Position Sensor
1128 Right Hand Lever Left/Right Position Sensor
1129 Right Attach Pedal
1130 Left Attach Pedal
1131 Lever Top Sig #1
1132 Lever Top Sig #4
1138 Boom Down
1139 Stick In/Stick Valve
1140 Stick Out
1141 Bucket Close/Bucket Valve
1142 Bucket Open
1143 Swing Right Solenoid
1144 Swing Left Solenoid
1145 Auxiliary Extend/Auxiliary Valve
1146 Auxiliary Retract
1147 Medium Pressure Circuit #1 - A Solenoid
1148 Medium Pressure Circuit #1 - B Solenoid
1149 Boom Lowering Check
1150 Swing Pump Swash Plate Angle Solenoid
1155 Implement Power Shift
1159 Stick Lowering Check
1160 Hydraulic Lock Solenoid
1163 Left Track Reverse
1164 Right Track Reverse
1165 Right Track Forward/Right Track Valve
1166 Left Track Forward/Left Track Valve
1191 Main Swing Valve
1192 Main Implement Valve
1193 Boom Up/Boom Valve
0096 Fuel Level Sensor
0262 Sensor Power Supply (5 DCV)
0263 Sensor Power Supply (8 or 12 DCV)
0295 VIDS - Machine Electronic Control Module
0324 Action (Warning) Lamp
0558 Machine Autolube Solenoid
0590 VIDS - Engine Electronic Control Module
0600 Hydraulic Oil Temperature Sensor
0811 Gauge Cluster
0815 Message Center
0820 Keypad Data Link
1073 Graphics Display
1178 Overload Warning Pressure Sensor
0001 Injector Cylinder 1
0002 Injector Cylinder 2
0003 Injector Cylinder 3
0004 Injector Cylinder 4
0005 Injector Cylinder 5
0006 Injector Cylinder 6
0091 Throttle Position
0094 Fuel Pressure
0100 Oil Pressure
0110 Coolant Temperature
0168 Battery Voltage
0172 Intake Air Temperature
0174 Fuel Temperature
0190 Engine Speed
0253 Personality Module
0261 Engine Timing Cal
0262 Analog Sensor
0268 Program Parameters/ECM Fault
0273 Turbo Out Press
0274 Atmospheric Pressure
0545 Start Aid
0799 Service Tool
E017 High Engine Coolant Temperature
E027
High Intake Air Temperature
E053
Low Fuel Pressure
E100
Low Engine Oil Pressure
E190
Engine Overspeed
² The MID is a diagnostic code that indicates which electronic control module
diagnosed the fault.
¹ The CID is a diagnostic code that indicates which component is faulty.
Component identifiers (CID¹) for
VIDS Module Identifier (MID051²)
Component identifiers (CID¹) for
Machine Electronic Control Module
Module Identifier (MID039²)
Component identifiers (CID¹) for
Engine Electronic Control Module
Module Identifier (MID036²)
Off Machine Switch Specification
Part No. Function Actuate Deactuate Contact Position
109-9330 Air Cleaner Switch
635±58 mm H
2
O
- N.O.
275 to 1750 kPa¹
(40 to 255 psi)
¹ A hysteresis band exists: with increasing pressure the closed condition can be maintained up to 2800 kPa (405 psi), with decreasing pressure
the closed position can be maintained down to 170 kPa (25 psi).
² Contact position at the contacts of the harness connector.
Refridgerant Low Press Switch114-5333 - N.O.
Machine Harness Connector And Component Locations
A
B
C
D
E
1
2
F
A
B
C
1
2
G
H
D
E
F
G
H
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
27
28
29
30
31
32
26
25
26
25
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
27
28
29 30
32
33
34
31
33
34
35
36
37
38
39
40
41
42
43
35
36
37
38
39
40
41
42
43
44
44
CONN 20
CONN 19
CONN 18
CONN 17
CONN 16
CONN 15
CONN 14
CONN 13
CONN 12
G
A
B
2
NEUTRAL START
LIMIT SW
A
J
111-4799
146-6706
YL
GR
BU
BK
C
J
5
4
6
2
GY
RD
+B
3
1
1
3
2
J
FLOW CONT LH-R (-)
HORN (-)
FLOW CONT LH-L (-)
FLOW CONT LH-L (+)
HORN (+)
FLOW CONT LH-R (+)
GND
PWM X
B
2
L34
OPERATOR STATION
L34
5
4
6
150-RD-18
200-BK-18
200-BK-18
200-BK-18
320-RD-18
M949-PK-18
M943-YL-18
M948-BR-18
M942-WH-18
M947-OR-18
151-GN-18
154-RD-18
A
XY
200-BK
-
5
7
8
6
9
10
12
11
SW CMH
SW Y
SW X
B
C
524-BU
118-GY
S
B+ 12V
PLATFORM
+ 12V LIGHT
MEMORY + 12V
118-GY
200-BK
200-BK-14
200-BK-14
200-BK
135-BU
139-OR-18
633-BU-18
L32
S
2
3
1
XY
524-BU
XY
M953-BU-18
M952-YL-18
M951-WH-18
4
M950-PU-18
PWM Y
3
ATCH
111-4846
3
1
2
8
7
MM
ANTENNA CABLE
L34
177-RD-10
130-RD-14
SPEAKER RH -
SPEAKER RH +
SPEAKER LH -
SPEAKER LH +
508-PU-18
509-WH-18
511-BR-18
512-GN-18
6
5
7
8
L35
XY
615-YL
512-GN-18
511-BR-18
509-WH-18
508-PU-18
A
XY
8
6
4
3
7
L35
L30
177-RD-10
130-RD-14
200-BK-18
103-RD-18
113-OR-18
5
1
2
130-RD-14
180-GN-14
176-YL-14
152-BU-14
XY
B
A
1
2
L31
A
C
J
J
AM/FM RADIO
GROUND
4
210-BK
+B
GND
PWM
-
A
2
1
4
3
5
6
200-BK
607-PK
M953-BU-18
M955-BR-18
M954-BU-18
M948-BR-18
M947-OR-18
GND
+B
A
2
4
3
1
-
6
9
8
7
10
11
12
5
M957-GY-18
M956-GN-18
M948-BR-18
M947-OR-18
M953-BU-18
M959-PK-18
M958-OR-18
L29
200-BK
M953-BU-18
M948-BR-18
M947-OR-18
200-BK
607-PK
M947-OR-18
M953-BU-18
M955-BR-18
M954-BU-18
M947-OR-18
M948-BR-18
M947-OR-18
M948-BR-18
M960-PU-18
M953-BU-18
M959-PK-18
M958-OR-18
M957-GY-18
M956-GN-18
M948-BR-18
+B
PWM
GND
-
1
A
2
3
5
4
6
M953-BR-18
M961-WH-18
M960-PU-18
M948-BR-18
M947-OR-18
146-6707
GR
BK
BU
GY
YL
RD
3
2
4
H
5
6
1
+B
-
1
3
2
5
8
7
6
4
H
FLOW CONT RH-R (+)
FLOW CONT RH-L (+)
FLOW CONT RH-L (-)
FLOW CONT RH-R (-)
SW X
SW Y
SW CMH
PWM X
GND
PWM Y
L21
M961-WH-18
M953-BU-18
M947-OR-18
M948-BR-18
M953-BU-18
L21
M953-BU-18
M965-GN-18
M964-BR-18
M963-BU-18
M962-YL-18
M948-BR-18
M947-OR-18
M945-BR-18
L972-BU-18
200-BK-18
200-BK-18
200-BK-18
M944-BU-18
L32
524-BU
200-BK-14
118-GY
200-BK-14
180-GN-14
210-BK
633-BU-18
139-OR-18
135-BU
176-YL-14
152-BU-14
180-GN-14
633-BU-18
139-OR-18
638-WH
135-BU
210-BK
118-GY
524-BU
L31
152-BU-14
176-YL-14
L31
L30
L28
L28
180-GN
8630-BU-18
578-BU-18
176-YL-14
152-BU-14
576-PK-18
200-BK-14
200-BK-14
200-BK-14
200-BK-14
176-OR-14
152-BU-14
638-WH
180-GN
L25
L23
L22
L29
L23
L21
L25
111-6458
ATCH
180-GN-18
152-BU-18
152-BU-18
180-GN-14
180-GN-18
180-GN
L22
SEAT WITH
SEAT HEATER
L22
L23
M960-PU-18
M961-WH-18
607-PK
M959-PK-18
M958-OR-18
M957-GY-18
M956-GN-18
M955-BR-18
M954-BU-18
M953-BU-18
M953-BU-18
M953-BU-18
M953-BU-18
M953-BU-18
M953-BU-18
M953-BU-18
M948-BR-18
M948-BR-18
M948-BR-18
M948-BR-18
M948-BR-18
M948-BR-18
M947-OR-18
M947-OR-18
M947-OR-18
M947-OR-18
M947-OR-18
M947-OR-18
J
BOOM LAMP
4
10A
10A
10A
15A
5A
114-RD
105-RD
148-RD
110-RD-18
175-RD-14
HORN
FAN
KEY SW
TIMER RELAY
BOOM LAMP
149-RD
10A
J
170-YL-10
10A
10A
10A
5A
5A
10A
178-RD-14
160-RD
103-RD-18
129-BU
152-BU-14
115-RD
176-YL-14
118-GY
10A
170-YL-10
115-RD
105-RD
178-RD-14
175-RD-14
176-YL-14
160-RD
114-RD
149-RD
148-RD
110-RD-18
185-YL-18
129-BU
118-GY
140-BU
147-PU-18
196-BU
124-GN
103-RD-18
120-YL
171-GN-10
152-BU-14
148-RD
110-RD-18
114-RD
154-RD-18
175-RD-14
115-RD
120-YL
2
12
1
A
9
10
8
6
7
11
J
J
149-RD
151-GN-18
105-RD
140-BU
185-YL-18
118-GY
124-GN
103-RD-18
129-BU
160-RD
5
4
2
1
3
7
8
6
4
5
A
J
L34
150-RD-18
M943-YL-18
M942-WH-18
M953-BU-18
M952-YL-18
180-GN-14
320-RD-18
154-RD-18
151-GN-18
M951-WH-18
200-BK
M949-PK-18
M948-BR-18
200-BK-18
200-BK-18
200-BK-18
M947-OR-18
M950-PU-18
147-PU-18
196-BU
178-RD-14
200-BK
M953-BU-18
M942-WH-18
M943-YL-18
320-RD-18
150-RD-18
3
2
12
1
A
9
10
8
7
11
J
M947-OR-18
M948-BR-18
M949-PK-18
M950-PU-18
M951-WH-18
177-RD-10
170-YL-10
171-GN-10
5
4
2
1
3
AA
JJ
M952-YL-186
5
J
5A
10A
15A
10A
5A
10A
171-GN-10
120-YL
140-BU
124-GN
180-GN-14
147-PU-18
185-YL-18
FUSE
5A 139-5345
10A 9W-1442
15A 9W-1441
196-BU
10A
L34
INSP LAMP
6
LUBRICATOR
AUX CKT
A/C /HEATER
SW PANEL
ACC CONVERTER
FUSE BASE
111-4812
CWTW REMOVAL
XY
L33
CONDENSOR
FAN RELAY
111-4871
2
7
3
6
4
8
1
5
L26
1
3
2
4
XY
6
2
5
L25
CONTROL GP
159-3665
XY A
200-BK
521-YL-18
200-BK
175-RD-14
593-GN-18
200-BK-18
514-PU
175-PK-14
615-YL
514-PU
593-GN-18
200-BK
200-BK
C538-OR-18
C537-GN-18
124-GN
521-YL-18
124-GN-14
AUX CKT
CAB LAMP
CIGAR LIGHTER
WASHER/WIPER
CHASSIS LAMP
DOME LAMP
AUX CKT
L30
615-YL
512-GN-18
511-BR-18
508-PU-18
509-WH-18
103-RD-18
200-BK-18
114-RD
115-RD
105-RD
140-BU
154-RD-18
151-GN-18
110-RD-18
103-RD-18
113-OR-18
113-OR-18
130-RD-14
L28
200-BK-14
578-BU-18
200-BK-14
576-PK-18
8630-BU-18
M947-OR-18
M948-BR-18
M953-BU-18
151-GN-18
154-RD-18
320-RD-18
196-BU
177-RD-10
200-BK
514-PU
130-RD-14
170-YL-10
171-GN-10
178-RD-14
149-RD
129-BU
118-GY
160-RD
196-BU
185-YL-18
147-PU-18
150-RD-18
320-RD-18
171-GN-10
200-BK
M943-YL-18
M942-WH-18
M953-BU-18
M952-YL-18
M951-WH-18
M950-PU-18
M949-PK-18
M948-BR-18
M947-OR-18
170-YL-10
149-RD
150-RD-18
140-BU
114-RD
147-PU-18
M943-YL-18
M942-WH-18
M952-YL-18
115-RD
110-RD-18
103-RD-18
521-YL-18
103-RD-18
103-RD-18
103-RD-18
M950-PU-18
200-BK
M949-PK-18
103-RD-18
160-RD
M951-WH-18
152-BU-14
176-YL-18
176-YL-18
176-YL-14
576-PK-18
152-BU-14
176-YL-14
578-BU-18
8630-BU-18
M953-BU-18
L21
M936-BR-18
308-YL
H807-YL-18
A768-BU
307-OR
X976-BU
F717-YL-18
F718-BU-18
K947-YL-18
M948-BR-18
M947-OR-18
L20
M945-BR-18
K946-OR-18
K943-OR-18
M965-GN-18
K944-YL-18
K950-YL-18
K949-OR-18
M964-BR-18
M963-BU-18
M962-YL-18
K952-BR-18
K948-GY-18
998-BR-18
A755-PK-18
A756-BU-18
A757-GY-18
A758-BR-18
L972-BU-18
791-RD-18
786-RD-18
M944-BU-18
L26
L27L29
L33
120-YL
124-GN
124-GN
124-GN
615-YL
175-RD-14
175-RD-14
521-YL-18
178-RD-14
200-BK
514-PU
200-BK
120-YL
C538-OR-18
C537-GN-18
200-BK
A
200-BK-14
200-BK
200-BK-18
200-BK
200-BK
200-BK-14
105-RD
200-BK-14
200-BK-14
124-GN
L24
118-GY
512-GN-18
511-BR-18
509-WH-18
508-PU-18
200-BK-14
200-BK-14
103-RD-18
615-YL
615-YL
185-YL-18
A
F
L20
129-BU
L7
L8
L19
K909-BU
P965-OR-18
P964-GY-18
P966-PK-18
K945-GY-18
200-BK-14
M946-GN-18
E720-GN-18
615-YL
615-YL
586-BR-18
L19L8
615-YL
615-YL
185-YL-18
A586-OR-18
501-GN-18
590-GY-18
615-YL
615-YL
124-GN
615-YL
105-RD
L24
L26
L20
L25
L6
L27
L23L24
L9
530-OR-18
524-BU
118-GY
C538-OR-18
210-BK
135-BU
638-WH
139-OR-18
633-BU-18
L27
C537-GN-18
308-YL
L19L7
177-RD-10200-BK
PLATFORM
K951-GY-18
1
120-YL
KEY SW
THROTTLE
POS SW
106-0107
9G-7641
H
R
9
10
12
11
ON
ST
S
B
S1
S3
S2
PK
GN
BU
2
4
3
H
C
OFF
111-4800
SWITCH PANEL
BK
MODE B
MODE A
1
6
6
7
8
H
WASH
W INT (6)
W LOW
W INT (3)
GND
+B
L CHASSIS
L BOOM
1
11
4
3
2
10
5
12
MODE SELECT
COM
5
BR S4
308-YL
308-YL
307-OR
105-RD
L10
P964-GY-18
P965-OR-18
P966-PK-18
A586-OR-18
530-OR-18
A758-BR-18
A757-GY-18
A756-BU-18
A755-PK-18
185-YL-18
791-RD-18
786-RD-18
501-GN-18
590-GY-18
200-BK-18
200-BK-18
200-BK-18
615-YL-18
180-GN-18
8630-BU-18
H
ATCH ROTATING
BEACON SW
L11
L10
200-BK-18
615-YL-18
615-YL-18
578-BU-18
176-YL-18
CKT SW
H
615-YL-18
200-BK-18
200-BK-18
152-BU-18
576-PK-18
615-YL-18
ATCH AUX
CKT SW
H
200-BK-18
ATCH AUX
200-BK-18
200-BK
200-BK-18
200-BK-18
200-BK-18
200-BK
200-BK-14
200-BK-18
1
2
H
200-BK
A537-PK
200-BK-18
200-BK-18
200-BK-18
200-BK-18
615-YL-18
M936-BR-18
200-BK-18
615-YL-18
200-BK-18
H
L11
L12
L10
124-GN
A537-PK
200-BK-18
615-YL-18
615-YL-18
H
L12
WINDSHIELD SW
E
E
2
5
E
WIND SW
1
9
3
4
7
6
OUTPUTS
GND IN
WASH SW
8
200-BK
500-BR-18
A586-OR-18
118-GY
506-PU
501-GN-18
524-BU
590-GY-18
500-BR-18
9G-2795 (NOTE E)
WIPER CONT
127-9838
200-BK-18
INTER SW
WIPER SW
MOT WASHER
+ 24V IN
L1
200-BK-14
403-GN-18
E
Y/G
Y/W
E
+
-
E
SERVICE
METER
6T-7337
C537-GN-18
C538-OR-18
129-BU
200-BK
F
7
8
6
2
1
3
5
4
L5
200-BK
103-RD-18
633-BU-18
139-OR-18
210-BK
120-YL
135-BU
615-YL-18
SENSOR
A/C PHOTO
128-2162
200-BK-18
200-BK-14
200-BK
200-BK-18
E
CAB
7Y-5505
F
512-GN-18
511-BR-18
509-WH-18
200-BK
CIGAR
200-BK-18
200-BK-14
ATCH SPEAKER(R)
ATCH SPEAKER(L)
LIGHTER
9W-0335
ATCH FLOW
CONT SW
111-4788
200-BK
KEY PAD
149-2356
ACTION
ALARM
3E-6328
1
3
2
E
4
AK (NOTE H)
3T-0304
1
2
E
E
AK (NOTE H)
AK (NOTE H)
DATA
GROUND
+V DISPLAY
ACTION LAMP
L1
615-YL
ATCH SEAT
HEATER SW
111-4783
E998-BR-18
411-PK-18
E997-YL-18
410-WH-18
C415-WH-18
P967-PU-18
E707-GN-18
GAUGE
CLUSTER
125-6235
2
4
3
6
E
5
AK (NOTE H)
1
3
2
ADDRESS
CLOCK
GROUND
DATA
LOAD
GROUND
+V DISPLAY
CLOCK
MESSAGE
CENTER
148-2949
L4
+B
5
6
2
4
3
1
7
6
8
2
1
5
CAN LOW
CAN SHIELD
CAN HIGH
N.C.
GROUND
CDL+
CDL-
LOAD
ADDRESS
ATCH ROTATING
BEACON LAMP
DATA
4
NOTE C
E
NOTE C
NOTE A
615-YL
615-YL
200-BK
200-BK
308-YL
AK (NOTE H)
893-GN-18
892-BR-18
200-BK-18
E708-PK-18
E708-PK-18
C413-YL-18
C413-YL-18
C414-BU-18
C414-BU-18
P967-PU-18
638-WH
200-BK
E707-GN-18
L2
+V DISPLAY
1
XY
H
11
2
4
5
6
12
3
H807-YL-18
180-GN-18
8630-BU-18
578-BU-18
176-YL-18
152-BU-18
576-PK-18
11
10
8
7
9
4
5
3
1
2
6
L972-BU-18
K947-YL-18
K949-OR-18
K950-YL-18
F718-BU-18
K944-YL-18
F717-YL-18
K943-OR-18
M936-BR-18
K946-OR-18
586-BR-18
185-YL-18
200-BK-18
200-BK-14
A756-BU-18
A757-GY-18
A758-BR-18
308-YL
307-OR
105-RD
791-RD-18
590-GY-18
501-GN-18
786-RD-18
L10
P965-OR-18
P964-GY-18
A755-PK-18
A586-OR-18
A
12
H
10
9
11
8
6
7
5
4
M953-BU-18
M965-GN-18
M964-BR-18
M963-BU-18
M962-YL-18
M948-BR-18
M947-OR-18
M945-BR-18
M944-BU-18
A
2
1
8
7
H
6
4
5
3
2
X976-BU
124-GN
P965-OR-18
P964-GY-18
E720-GN-18
A758-BR-18
A757-GY-18
A756-BU-18
A755-PK-18
P966-PK-18
3
P966-PK-18
M953-BU-18
M965-GN-18
M964-BR-18
M963-BU-18
M962-YL-18
M948-BR-18
M947-OR-18
M944-BU-18
M945-BR-18
308-YL
530-OR-18
176-YL-18
180-GN-18
124-GN
576-PK-18
152-BU-18
578-BU-18
L11L12
M936-BR-18
8630-BU-18
L972-BU-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18
586-BR-18
615-YL-18
615-YL-18
H
200-BK-18
E720-GN-18
998-BR-18
200-BK-18
L14
615-YL-18
615-YL-18
H
H
H
2
1
H
3
H
1
5
3
4
6
1
H
H
2
BACKUP SW
(TRAVEL LEFT)
9G-0011
BACKUP SW
(BOOM)
7N-8008
A
8
H
5
6
7
A
4
2
3
1
H
A768-BU
308-YL
307-OR
308-YL
K909-BU
200-BK-14
K952-BR-18
11
10
7
8
9
6
5
3
2
4
105-RD
530-OR-18
590-GY-18
501-GN-18
615-YL-18
K948-GY-18
K951-GY-18
K945-GY-18
786-RD-18
791-RD-18
998-BR-18
12
615-YL-18
L14L15
K948-GY-18
K946-OR-18
K951-GY-18
K949-OR-18
K950-YL-18
K947-YL-18
K945-GY-18
K944-YL-18
E720-GN-18
X976-BU
K909-BU
K909-BU
A768-BU
K909-BU
308-YL
998-BR-18
200-BK-18
L16
L17
F718-BU-18
F717-YL-18
K943-OR-18
A
H
L7
L8
L9
L6
308-YL
K952-BR-18
A586-OR-18H807-YL-18
1
K909-BU
X976-BU
L15
L16
K909-BU
K909-BU
200-BK-18
A768-BU
200-BK-18
200-BK-18
200-BK-18
H
1
6
3
H
2
5
MAIN BACKUP SW
114-0421
9
7
10
12
8
11
4
L17
308-YL
K952-BR-18
308-YL
H807-YL-18
185-YL-18
K951-GY-18
K949-OR-18
K950-YL-18
K945-GY-18
K944-YL-18
K943-OR-18
1
586-BR-18
ATCH OLWD
CANCEL SW
132-1828
200-BK-14
200-BK
200-BK
411-PK-18
E997-YL-18
200-BK
410-WH-18
200-BK-18
200-BK-14
E707-GN-18
P967-PU-18
E707-GN-18
P967-PU-18
P967-PU-18
E707-GN-18
E998-BR-18
L1
200-BK-14
C538-OR-18
C537-GN-18
2
3
(TRAVEL RIGHT)
9G-0011
118-GY
501-GN-18
590-GY-18
403-GN-18
129-BU
118-GY
118-GY
506-PU
A586-OR-18
E707-GN-18
524-BU
118-GY
524-BU
524-BU
524-BU
118-GY
ATCH START
AID SW
111-4784
E708-PK-18
C413-YL-18
E708-PK-18
C413-YL-18
C413-YL-18
E708-PK-18
308-YL
892-BR-18
C415-WH-18
C414-BU-18
C414-BU-18
893-GN-18
C414-BU-18
NOTE C
615-YL
615-YL
615-YL
200-BK
638-WH
210-BK
200-BK-18
103-RD-18
508-PU-18
509-WH-18
511-BR-18
512-GN-18
118-GY
524-BU
135-BU
615-YL
P967-PU-18
E708-PK-18
C415-WH-18
C413-YL-18
C414-BU-18
410-WH-18
E997-YL-18
411-PK-18
615-YL
892-BR-18
893-GN-18
E998-BR-18
308-YL
524-BU
118-GY
120-YL
135-BU
210-BK
210-BK
210-BK
633-BU-18
139-OR-18
638-WH
210-BK
615-YL-18
615-YL
615-YL
615-YL
509-WH-18
508-PU-18
512-GN-18
511-BR-18
135-BU
E
E
1
2
XY
XY
200-BK-18
E
2
1
1
A
3
2
5
4
E
7
9
8
11
1
12
A
10
6
2
H
H
1
3
C537-GN-18
C538-OR-18
118-GY
L7
L8
L9
998-BR-18
F718-BU-18
F717-YL-18
308-YL
530-OR-18
633-BU-18
139-OR-18
638-WH
135-BU
210-BK
524-BU
615-YL
200-BK-14
501-GN-18
A586-OR-18
615-YL
615-YL
129-BU
590-GY-18
L9
L8
998-BR-18
BACKUP SW
(G/A)
110-7884
2
3
4
5
6
7
8
9
E
10
11
12
F
1
2
F
44
5
3
6
1
2
1
1
A
2
3
4
5
7
8
6
XY
F
C538-OR-18
118-GY
511-BR-18
512-GN-18
508-PU-18
509-WH-18
200-BK-14
103-RD-18
P967-PU-18
E708-PK-18
E707-GN-18
C537-GN-18
410-WH-18
E997-YL-18
411-PK-18
E998-BR-18
L7
L6
C415-WH-18
C414-BU-18
506-PU-18
403-GN-18
893-GN-18
892-BR-18
120-YL
BK/PK
ATCH
TRAVEL ALARM
C413-YL-18
615-YL
308-YL
410-WH-18
E997-YL-18
411-PK-18
893-GN-18
892-BR-18
511-BR-18
512-GN-18
524-BU
508-PU-18
509-WH-18
615-YL
103-RD-18
P967-PU-18
118-GY
524-BU
118-GY
C538-OR-18
403-GN-18
501-GN-18
590-GY-18
506-PU-18
200-BK-14
118-GY
E998-BR-18
E707-GN-18
E708-PK-18
C413-YL-18
C414-BU-18
C415-WH-18
C537-GN-18
A586-OR-18
129-BU
K948-GY-18
K947-YL-18
210-BK
135-BU
120-YL
638-WH
139-OR-18
200-BK-14
633-BU-18
118-GY
524-BU
K946-OR-18
BACKUP SW
GND
L4
L3
ATCH
ANTENNA
106-0036
160-RD
103-RD-18
130-RD-14
521-YL-18
147-PU-18
M949-PK-18
M950-PU-18
M951-WH-18
M952-YL-18
M942-WH-18
M943-YL-18
7
G
C
G
FOR
Z
Z
G
TIMER RELAY
132-1817
G
196-BU
200-BK
308-YL-18
INSP LAMP
9R-7941
115-RD
114-RD
140-BU
149-RD
196-BU
320-RD-18
154-RD-18
151-GN-18
514-PU
178-RD-14
177-RD-10
170-YL-10
150-RD-18
150-RD-18
171-GN-10
607-PK
607-PK
607-PK
M948-BR-18
M947-OR-18
M953-BU-18
M953-BU-18
L36
M961-WH-18
M959-PK-18
M958-OR-18
M957-GY-18
M956-GN-18
M955-BR-18
M954-BU-18
M960-PU-18
150-RD-18
OUT 1
+B
GND
GND
OUT 2
ETHER
161-3128
RELAY
200-BK-18
G
200-BK-18
110-RD-18
200-BK-18
200-BK-18
308-YL-18
317-YL-18
310-PU-18
308-YL-18
150-RD-18
HORN
RELAY
161-3128
G
HYD LOCK
SOL RELAY
161-3128
200-BK-18
114-RD
322-GY
G
114-RD-18
320-RD-18
200-BK-18
E997-BR
E997-BR
K924-YL
151-GN-18
110-RD-18
308-YL-18
IN 1
J
H
F
B
A
D
E
ATT
REFUEL
BREAKER
G
30A
15A
G
BREAKER 6
6T-3643
139-4724
892-BR-18
893-GN-18
200-BK-18
E793-BU-18
E794-YL-18
308-YL-18
8
BAT BREAKER 2BAT BREAKER 1
RELAY PANEL
G
G
15A
G
15A
G
BREAKER 4
6T-3643
G
15A
G
BREAKER 5
6T-3643
SS
RR
LL
30A
BREAKER 2
139-4724
30A
TT
PP
BREAKER 3
139-4724
30A
BUS BAR
139-4724 6T-3643
G
NEUTRAL
START RELAY
200-BK-18
307-OR
154-RD-18
G
RELAY
BOOM LAMP
161-3128
G
RELAY
AUTO LUB
161-3128
386-PK
149-RD
786-RD-18
149-RD-18
140-BU
140-BU
559-YL-18
801-PK-18
616-BU
161-3128
133-RD-14
101-RD-14
131-RD-14
130-RD-14
178-RD-14
101-RD-14
101-RD-14
101-RD-14
177-RD-10
171-GN-10
170-YL-10
112-PU-6
130-RD-14
ET CONN AND ECAP CONN
586-BR-18
P966-PK-18
P965-OR-18
P964-GY-18
E720-GN-18
X976-BU
K909-BU
998-BR-18
A757-GY-18
A756-BU-18
A755-PK-18
K948-GY-18
K951-GY-18
K952-BR-18
H807-YL-18
K945-GY-18
786-RD-18
791-RD-18
L972-BU-18
A758-BR-18
M945-BR-18
M944-BU-18
M962-YL-18
M963-BU-18
K947-YL-18
K949-OR-18
K950-YL-18
K944-YL-18
F717-YL-18
K943-OR-18
K946-OR-18
M965-GN-18
M964-BR-18
RESISTOR
102-8017
BACKUP
RESISTOR
(BLCV)
102-8017
G
RELAY
161-3128
P944-GY
X977-YL
112-PU-18
115-RD
791-RD-18
115-RD-18
200-BK-18
CAB LAMP
RELAY
161-3128
G
200-BK-18
200-BK-18
200-BK-18
607-PK
G
160-RD
607-PK-18
615-YL
M941-GY-18
M941-GY-18
200-BK-18
332-BU-18
CHASSIS LAMP
SUCTION LINE
SHUTOFF RELAY
A768-BU
307-OR
308-YL
615-YL
615-YL
120-YL
M936-BR-18
F718-BU-18
411-PK-18
E998-BR-18
E997-YL-18
P967-PU-18
C413-YL-18
E708-PK-18
E707-GN-18
410-WH-18
L37
L36
506-PU-18
403-GN-18
893-GN-18
892-BR-18
180-GN
C415-WH-18
C414-BU-18
638-WH
576-PK-18
200-BK-14
578-BU-18
176-OR-14
200-BK-14
152-BU-14
L37
J2
161-3128
70
68
69
67
64
61
60
57
58
59
VIDS
142-5076
62
+8V ANLG
LIGHT SW
SPD +2
STB 3
STB 4
56
54
51
50
52
46
45
44
42
43
47
SPD -2
A/P 5
SPD -1
A/P 4
A/P 3
APS +1
MAIN RELAY
165-4026
200-BK-18
308-YL-18
200-BK-18
101-RD-6
200-BK-18
101-RD-14
101-RD-14
101-RD-14
112-PU-18
308-YL-18
200-BK-18
308-YL-18
112-PU-6
101-RD-14
G
2
1
NN
BACKUP
RESISTOR
BACKUP
RESISTOR
(TR LH)
151-9360
306-GN
109-RD-8
125-1302
1
2
1
G
G
304-WH-8
START RELAY
MM
DIODE
121-4871
G
G
DIODE
121-1022
DIODE
DIODE
121-1022
121-1022
E997-BR
K909-BU
X976-BU
X976-BU
X976-BU
X977-YL
P946-BR
G
G
DIODE
121-1022
K909-BU
BACKUP
F859-GY
F859-GY
K951-GY-18
K945-GY-18
H733-BU-18
M935-BU-18
H733-BU-18
RESISTOR
145-3084
K909-BU
K945-GY-18
K909-BU
K909-BU
151-9360
2
41
40
38
35
39
33
32
31
29
30
34
RS232 TXD 2
RS232 RXD 2
CAN SHIELD
RS232 RXD 1
RS232 TXD 1
27
26
24
23
25
18
21
17
15
16
22
CANL
K948-GY-18
14
13
11
9
12
8
6
7
5
4
CANH
STG 20
2
1
55
65
66
615-YL
63
49
53
48
37
495-GN-18
K909-BU
+V DISPLAY
LOWERING CHECK
POWER HYD TEMP
LIGHT SW
BUCKUP SW
STG 19
3
P969-BR-18
E707-GN-18
E996-WH-18
H447-YL-18
H446-PK-18
K948-GY-18
RELAY PANEL
(TR RH)
709-OR 200-BK-18
MAIN RELAY
120-YL
DISCONNECT SW.
LL
80A
HH
JJ
BREAKER 1
9S-4693
7N-0718
7N-0719(NOTE B)
9
E793-BU-18
E794-YL-18
P946-BR
P944-GY
E997-BR
M935-BU-18
310-PU-18
893-GN-18
892-BR-18
317-YL-18
GB
1
2
4
3
6
5
8
10
9
7
200-BK-18
308-YL-18
196-BU
114-RD
110-RD-18
150-RD-18
310-PU-18
317-YL-18
P944-GY
308-YL-18
177-RD-10
101-RD-4
109-RD-4
171-GN-10
170-YL-10
130-RD-14
178-RD-14
130-RD-14
101-RD-14
101-RD-14
101-RD-14
101-RD-14
112-PU-6
112-PU-6
133-RD-14
131-RD-14
K924-YL
E997-BR
E997-BR
151-GN-18
320-RD-18
200-BK-18
200-BK-18
X977-YL
308-YL-18
101-RD-14
101-RD-14
101-RD-14
101-RD-14
308-YL-18
112-PU-18
112-PU-18
101-RD-14
101-RD-14
101-RD-14
304-WH-8
317-YL-18
K909-BU
101-RD-6
109-RD-8
196-BU
K951-GY-18
K948-GY-18
K945-GY-18
332-BU-18
M935-BU-18
M941-GY-18
M941-GY-18
101-RD-14 322-GY
K924-YL
200-BK
131-RD-14
130-RD-14
109-RD-4
168-RD-10
101-RD-10
101-RD-6
101-RD-4
109-RD-8
G
12
2
1
B
3
4
JJ
MM
B
HH
KK
B
B
304-WH-8
177-RD-10
171-GN-10
140-BU
307-OR
170-YL-10
151-GN-18
NNB
SS
RR
A
A
TTA
A
2
1
3
4
G
101-RD-4
109-RD-4
11
10
L38
200-BK-14
200-BK-18
GND STRAP
132-1805
235-BK-14
235-BK-14
200-BK
506-PU-18
514-PU
317-YL-18
430-BU-18
412-BU-18
310-PU-18
403-GN-18
403-GN-18
109-RD-4
235-BK-14
235-BK-14
200-BK
235-BK-14
235-BK-14
235-BK-14
235-BK-14
200-BK
200-BK-14
200-BK
235-BK-14
K924-YL
P946-BR
E997-BR
L39
L40
412-BU-18
430-BU-18
892-BR-18
788-YL-18
893-GN-18
235-BK-14
235-BK-14
506-PU-18
514-PU
403-GN-18
AB
101-RD-4
304-WH-8
521-YL-18
788-YL-18
308-YL
998-BR-18
893-GN-18
893-GN-18
893-GN-18
L49
F718-BU-18
F717-YL-18
E794-YL-18
E793-BU-18
M953-BU-18
F889-WH-18
3
2
4
9
7
6
8
5
10
12
11
A
1
B
3
2
892-BR-18
892-BR-18
200-BK-14
130-RD-14
130-RD-14
131-RD-14
131-RD-14
131-RD-14
131-RD-14
130-RD-14
130-RD-14
130-RD-14
C468-BU-18
E720-GN-18
892-BR-18
1
168-RD-10
C468-BU-18
E794-YL-18
E793-BU-18
101-RD-4
304-WH-8
109-RD-4
892-BR-18
893-GN-18
M953-BU-18
317-YL-18
310-PU-18
P944-GY
F889-WH-18
M937-GN-18
130-RD-14
131-RD-14
M938-GY-18
M935-BU-18
403-GN-18
L39
307-OR
386-PK
616-BU
149-RD
154-RD-18
559-YL-18
786-RD-18
140-BU
140-BU
709-OR
306-GN
109-RD-8
304-WH-8
200-BK-18
101-RD-6
801-PK-18
559-YL-18
801-PK-18
154-RD-18
386-PK
151-GN-18
307-OR
E997-BR
140-BU
607-PK
615-YL
709-OR
160-RD
115-RD
786-RD-18
791-RD-18
140-BU
E997-BR
K909-BU
K951-GY-18
K948-GY-18
308-YL-18
112-PU-6
X977-YL
K945-GY-18
P946-BR
X976-BU
115-RD
607-PK
M941-GY-18
M941-GY-18
332-BU-18
791-RD-18
M935-BU-18
308-YL-18
322-GY
114-RD
616-BU
150-RD-18
320-RD-18
149-RD
110-RD-18
P944-GY
310-PU-18
200-BK
200-BK-18
P946-BR
X976-BU
200-BK
200-BK-18
306-GN
607-PK
K948-GY-18
K945-GY-18
150-RD-18
130-RD-14
X976-BU
K951-GY-18
308-YL-18
320-RD-18
786-RD-18
178-RD-14
G
6
1
3
4
5
2
8
7
9
10
G
1
A
12
11
6
114-RD
115-RD
160-RD
K909-BU
149-RD
154-RD-18
791-RD-18
110-RD-18
306-GN
616-BU
140-BU
386-PK
709-OR
322-GY
332-BU-18
615-YL
2
3
5
4
7
9
8
6
11
1
A
12
3
2
5
4
10
160-RD
615-YL
200-BK-18
200-BK-18
RELAY
PANEL
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18
C413-YL-18
28
20
A
10
19
DIGITAL RET
DISPLAY LOAD
DISPLAY DATA
DISPLAY CLOCK
615-YL
P967-PU-18
491-PK-18
495-GN-18
C414-BU-18
E708-PK-18
P969-BR-18
K909-BU
235-BK-14
H446-PK-18
H447-YL-18
E707-GN-18
133-RD-14
133-RD-14
133-RD-14
133-RD-14
E996-WH-18
E708-PK-18
C414-BU-18
C413-YL-18
P967-PU-18
G
M941-GY-18
801-PK-18
559-YL-18
M941-GY-18
133-RD-14
7
6
9
8
10
12
11
L44
L44
801-PK-18
200-BK-18
C468-BU-18
788-YL-18
F889-WH-18
M941-GY-18
403-GN-18
430-BU-18
412-BU-18
403-GN-18
200-BK-14
559-YL-18
M941-GY-18
403-GN-18
133-RD-14
235-BK-14
235-BK-14
L41
521-YL-18
403-GN-18
998-BR-18
K909-BU
151-GN-18
L37
180-GN
200-BK-14
576-PK-18
638-WH
5
7
6
9
12
10
11
8
A
1
B
2
4
5
3
6
235-BK-14
235-BK-14
235-BK-14
235-BK-14
K909-BU
235-BK-14
L48
P946-BR
E997-BR
151-GN-18
K946-OR-18
K947-YL-18
K949-OR-18
K952-BR-18
K950-YL-18
P965-OR-18
P964-GY-18
8
7
9
10
12
11
XY
B
A
XY
1
2
C
P944-GY
K924-YL
K943-OR-18
K944-YL-18
M935-BU-18
H807-YL-18
ATCH AUX.
ATCH BEACON
RELAY
M938-GY-18
M937-GN-18
K950-YL-18
K952-BR-18
K949-OR-18
K947-YL-18
K946-OR-18
K944-YL-18
K943-OR-18
F717-YL-18
F718-BU-18
P964-GY-18
P965-OR-18
E720-GN-18
H807-YL-18
8630-BU-18
L38
L42
L40
L43
L41
L37
578-BU-18
152-BU-14
176-OR-14
200-BK-14
P965-OR-18
P964-GY-18
514-PU
H807-YL-18
L41
403-GN-18
521-YL-18
F718-BU-18
F717-YL-18
998-BR-18
E720-GN-18
M953-BU-18
506-PU-18
K943-OR-18
K944-YL-18
K946-OR-18
K947-YL-18
K949-OR-18
K952-BR-18
K909-BU
308-YL
K950-YL-18
XY
4
3
1
4
3
2
L36
ATCH AUX.
CIRCUIT
CIRCUIT
ATCH SENSOR
L42
L43
L40
L38
L36
L37
200-BK-18
4
196-BU K924-YL
131-RD-14
5
308-YL
101-RD-10491-PK-18
36
J1
7G-1060
GROUND STRAP
70
68
69
66
67
61
62
54
55
60
STG 18
STG 17
STG 16
63
53
52
50
49
51
STG 14
STG 15
STG 13
44
45
39
40
41
48
500Hz PWM 9
500Hz PWM10
J1
61
64
66
65
63
51
57
48
43
42
60
MACHINE CONTROL
151-2099
STG 26
STG 27
STG 28
STG 29
BACK LIGHT
RS232 TX1
RS232 TX2
STG 4
33
40
34
35
41
CANH
23
31
18
19
20
32
ANLG/PWM 5K
ANLG/PWM 5K
ANLG/PWM 5K
DIR/PASSIVE (1-)
DIR/PASSIVE (1+)
RS232 RX1
RS232 RX2
DIR/PASSIVE (2-)
DIR/PASSIVE (2+)
CAN SHLD
STB 4
SPI CLOCK
SPI DATA
SPI LOAD
LOW CUR SINK DR2
LOW CUR SINK DR1
LOW CUR SINK DR3
PRCP DR20
NEUTRAL FLOW BYPASS
BOOM (RETRACT)
DRIFT REDUCTION VALVE STICK
LH TRAVEL (REAR)
LH TRAVEL (FRONT)
RH TRAVEL (FRONT)
RH TRAVEL (REAR)
PLATFORMCHASSIS
38
37
31
30
36
25
28
24
22
23
LAMP RET1
LAMP HS1
29
500Hz PWM 8
500Hz PWM 7
500Hz PWM 6
500Hz PWM 5
21
20
12
11
13
64
8
59
43
65
10
MC BACK LIGHT
O.L.W.D CANCEL SW
500Hz PWM 3
ACTION ALARM (-)
500Hz PWM 4
500Hz PWM1
500Hz PWM 2
E997-YL-18
586-BR-18
58
57
47
46
56
KEY PAD
34
35
42
32
33
AUTO LUB PISTON SW STICK
AUTO LUB PISTON SW BOOM
AUTO LUB PISTON SW SWING
KEY SW (ON)
AUTO LUB (-)
ACTION LAMP (RED)(+)
ACTION LAMP (RED)(-)
ACTION ALARM (+)
ALTERNATOR (R TERM)
26
19
17
16
18
9
6
7
5
4
ENG OIL LEVEL SW
SUCTION SHUT OFF
AUTO LUB (+)
AIR CLEANER SENSOR
HYD OIL LEVEL SW
CAT DATA LINK (-)
AUTO LUB LOW LEVEL
CAT DATA LINK (+)
SUCTION SHUT OFF
27
410-WH-18
C415-WH-18
403-GN-18
559-YL-18
308-YL
E998-BR-18
411-PK-18
H441-GN-18
H443-BR-18
H442-YL-18
M941-GY-18
430-BU-18
E456-WH-18
M941-GY-18
892-BR-18
893-GN-18
C468-BU-18
496-WH-18
801-PK-18
P968-OR-18
CANL
26
17
11
10
6
67
58
69
62
68
70
KEY SW (ON)
ATT PUMP PRESS SW
KEY PAD
FAN SPEED SENSOR
+8V-SNR
+5V-SNR
53
52
56
54
55
45
46
39
47
44
49
NEUTRAL SW LH-X
NEUTRAL SW RH-X
PUMP PRESS SENSOR
FLOW CONT ROCKER SW
THROTTLE DIAL S2
PROD DR RET
PROD DR RET
PROD DR RET
BOOM (EXTEND)
DRIFT REDUCTION VALVE BOOM
MED.PRESS CIRCUIT 1-B
MED.PRESS CIRCUIT 1-A
SYSTEM PRESS UP-R
SYSTEM PRESS UP-F
LOWERING CHECK STICK
LOWERING CHECK BOOM
SWING (RH)
SWING (LH)
ON/OFF RET
PROD DR RET
ATT EXTEND
TRAVEL SPEED SHIFT SOL
SWING BRAKE SOL
HAMMER 2 SPEED SOL
RADIATOR FAN SPEED
ON/OFF RETURN
CTWT REMOVAL SW
ONE TOUCH LOW IDLE SW
NEUTRAL SW (TRV RH PEDAL)
NEUTRAL SW (HAMMER PEDAL)
GAIN/RESPONSE SELECT SW
NEUTRAL SW (TRV LH PEDAL)
NEUTRAL SW (STR TRV PEDAL)
SWING PUMP PRESS SENSOR
FLOW CONT PROXIMITY SW #2
FLOW CONT PROXIMITY SW #1
36
30
38
37
29
25
50
28
24
27
NEUTRAL SW LH-Y
NEUTRAL SW RH-Y
ENGINE SPEED
THROTTLE DIAL S1
THROTTLE DIAL S4
THROTTLE DIAL S3
16
15
59
21
14
8
7
12
13
9
TRAVEL RIGHT PEDAL
CAT DATA LINK (+)
CAT DATA LINK (-)
JOYSTICK +12V
SW COMMON
JOYSTICK GND
22
PROD DR RET
PROD DR RET
TRAVEL ALARM
ATT RETRACT
PS PRESS SOL
SWING PUMP SWASH
BUCKET (RETRACT)
BUCKET (EXTEND)
STICK (EXTEND)
HYD LOCK SW
BUCKUP SW
GND
GND
GND
GND
GND
GAIN/RESPONSE IND2
HYDRAULIC LOCK SOL
GAIN/RESPONSE IND1
STICK (RETRACT)
RH JOYSTICK (Y-AX1S)
LH JOYSTICK (Y-AX1S)
LH JOYSTICK (X-AX1S)
LEVER TOP SW FLOW CONT RH-R
STRAIGHT TRAVE PEDAL
LEVER TOP SW FLOW CONT LH-L
LEVER TOP SW FLOW CONT LH-R
LEVER TOP SW FLOW CONT RH-L
P966-PK-18
M948-BR-18
M953-BU-18
M936-BR-18
M938-GY-18
M960-PU-18
C472-GN-18
G426-WH-18
M963-BU-18
M950-PU-18
M949-PK-18
M965-GN-18
M952-YL-18
M951-WH-18
M964-BR-18
M956-GN-18
M955-BR-18
M958-OR-18
M959-PK-18
M961-WH-18
788-YL-18
M943-YL-18
M942-WH-18
M945-BR-18
892-BR-18
893-GN-18
A758-BR-18
A757-GY-18
A756-BU-18
A755-PK-18
M944-BU-18
L972-BU-18
M937-GN-18
M947-OR-18
A768-BU
L6
8
P945-OR-18
K947-YL-18
K946-OR-18
K944-YL-18
K943-OR-18
K949-OR-18
P955-BU-18K952-BR-18
K932-BU-18
K934-BR-18
P958-PK-18
K907-BU-18
321-BR-18
1
B
321-BR-18
L54
L54
K907-BU-18
321-BR-18
E790-PK-18
E790-PK-18
M933-PU-18
M933-PU-18
M933-PU-18
K932-BU-18
K934-BR-18
M933-PU-18
K949-OR-18
K949-OR-18
K949-OR-18
P958-PK-18
E790-PK-18
E790-PK-18
E790-PK-18
K929-GN-18
E790-PK-18
P943-GN-18
FLOW CONT
WH-18
WH-18
12
3 4
1
4
3
2
WH-18
WH-18
FLOW CONT
3E-5181
200-BK-18
M938-GY-18
M937-GN-18
AS
PROXIMITY SW 1
M933-PU-18
P946-BR
P944-GY
K952-BR-18
P943-GN-18
P949-PU-18
P950-YL-18
K950-YL-18
H807-YL-18
E790-PK-18
K932-BU-18
K934-BR-18
L982-PK-18
E998-YL-18
H716-WH-18
K907-BU-18
F853-BR-18
P957-BR-18
L57
K943-OR-18
K946-OR-18
K931-GN-18
K949-OR-18
P950-YL-18
P949-PU-18
K927-BU-18
P945-OR-18
P957-BR-18
K929-GN-18
K928-GN-18
E789-PU-18
E789-PU-18
K944-YL-18
K947-YL-18
K930-GN-18
K950-YL-18
H807-YL-18
E789-PU-18
F853-BR-18
M935-BU-18
E789-PU-18
K927-BU-18
K930-GN-18
K931-GN-18
K929-GN-18
9
6
M935-BU-18
321-BR-18
P958-PK-18
P959-GN-18
K909-BU
E997-BR
P965-OR-18
P964-GY-18
151-GN-18
2
235-BK-14
235-BK-14
235-BK-14
235-BK-14
235-BK-14
K928-GN-18
3
E998-YL-18
P946-BR
E790-PK-18
P955-BU-18
M933-PU-18
H716-WH-18
P959-GN-18
L982-PK-18
P943-GN-18
P944-GY
P946-BR
K950-YL-18
P946-BR
K952-BR-18
K949-OR-18
K947-YL-18
K946-OR-18
K944-YL-18
K943-OR-18
M935-BU-18
K943-OR-18
K943-OR-18
K943-OR-18
K946-OR-18
K946-OR-18
P950-YL-18
P949-PU-18
K927-BU-18
P945-OR-18
K928-GN-18
H807-YL-18
K946-OR-18
K931-GN-18
H807-YL-18
P955-BU-18
P957-BR-18
H807-YL-18
M938-GY-18
M937-GN-18
B
AS
K924-YL
200-BK-18
M938-GY-18
M937-GN-18
K949-OR-18
P958-PK-18
K929-GN-18
P944-GY
K943-OR-18
2
3
4
5
6
7
8
C
B
A
P946-BR
K944-YL-18
K944-YL-18
K930-GN-18
E789-PU-18
K950-YL-18
K950-YL-18
K950-YL-18
K947-YL-18
K947-YL-18
K947-YL-18
F853-BR-18
M935-BU-18
M935-BU-18
M935-BU-18
K952-BR-18
K944-YL-18
B
P943-GN-18
P950-YL-18
P949-PU-18
K928-GN-18
K946-OR-18
K931-GN-18
P945-OR-18
P955-BU-18
P957-BR-18
1
X
12
11
10
9
8
7
6
5
B
K930-GN-18
F853-BR-18
M935-BU-18
K950-YL-18
M933-PU-18
K944-YL-18
K947-YL-18
X
1
9
8
7
11
10
12
3
2
P946-BR4
J2
58
11
52
59
26
49
44
45
13
39
38
18
37
35
22
56
34
31
33
32
36
12
24
17
46
69
27
53
68
67
20
25
48
4
41
64
51
29
66
21
28
63
14
61
10
54
65
60
50
40
19
43
42
55
5
7
62
15
16
30
15
2
+B
1
+B
14
GND
GND
E456-WH-18
801-PK-18
496-WH-18
235-BK-14
412-BU-18
C468-BU-18
893-GN-18
892-BR-18
H442-YL-18
M941-GY-18
430-BU-18
M941-GY-18
411-PK-18
E998-BR-18
P968-OR-18
H441-GN-18
235-BK-14
235-BK-14
133-RD-14
133-RD-14
F889-WH-18
559-YL-18
403-GN-18
C415-WH-18
410-WH-18
E997-YL-18
308-YL
586-BR-18
403-GN-18
893-GN-18
892-BR-18
M957-GY-18
M962-YL-18
M954-BU-18
M953-BU-18
M948-BR-18
H443-BR-18
A
M948-BR-18
892-BR-18
893-GN-18
893-GN-18
892-BR-18
893-GN-18
893-GN-18
893-GN-18
892-BR-18
892-BR-18
M938-GY-18
M937-GN-18
615-YL
E998-BR-18
411-PK-18
E997-YL-18
M944-BU-18
L972-BU-18
410-WH-18
C415-WH-18
M947-OR-18
C414-BU-18
E708-PK-18
E707-GN-18
M936-BR-18
P967-PU-18
308-YL
A768-BU
586-BR-18
C413-YL-18
1
4
2
3
A
HAMMER PEDAL
TRAVEL LEFT PEDAL
M944-BU-18
M945-BR-18
M942-WH-18
M943-YL-18
M956-GN-18
M950-PU-18
M963-BU-18
M960-PU-18
A755-PK-18
A757-GY-18
A758-BR-18
788-YL-18
M952-YL-18
M965-GN-18
M949-PK-18
P966-PK-18
+B
+B
+B
+B
L972-BU-18
M955-BR-18
M964-BR-18
M951-WH-18
G426-WH-18
C472-GN-18
M936-BR-18
A768-BU
M937-GN-18
M938-GY-18
M961-WH-18
M959-PK-18
M958-OR-18
130-RD-14
130-RD-14
131-RD-14
RH JOYSTICK (X-AX1S)
THROTTLE POSITION (TO ENGINE ECM)
A756-BU-18
M961-WH-18
M959-PK-18
M958-OR-18
M955-BR-18
M956-GN-18
M957-GY-18
M942-WH-18
A758-BR-18
A757-GY-18
A756-BU-18
A755-PK-18
M952-YL-18
M965-GN-18
M964-BR-18
M951-WH-18
M943-YL-18
P969-BR-18
M953-BU-18
M962-YL-18
M950-PU-18
M963-BU-18
M954-BU-18
P966-PK-18
M960-PU-18
E456-WH-18
491-PK-18
496-WH-18
495-GN-18
H441-GN-18
E996-WH-18
K909-BU
P968-OR-18
M949-PK-18
M945-BR-18 M947-OR-18
M954-BU-18
M962-YL-18
M957-GY-18
F889-WH-18
L42
615-YL
151-GN-18
151-GN-18
X976-BU
130-RD-14
151-GN-18
791-RD-18
K945-GY-18
K948-GY-18
K951-GY-18
177-RD-10
178-RD-14
786-RD-18
160-RD
607-PK
154-RD-18
196-BU
114-RD
110-RD-18
140-BU
115-RD
307-OR
149-RD
150-RD-18
K909-BU
K909-BU
308-YL
170-YL-10
171-GN-10
K909-BU
320-RD-18
SENSOR
PRIM SPEED/TIMING
+V ENG SP/TMG
+V ENG SP/TMG
ENG SP/TMG COMMON
ENG SP/TMG
SENSOR
+5V
ENG SP/TMG
ENG SP/TMG COMMON
SENSOR COMMON
FUEL PRESSURE
FUEL PRESSURE
BACKUP SPEED/TIMING
L36
SENSOR
+5V
SENSOR
ATM PRESSURE
INLET MANF PRESSURE
SENSOR COMMON
+5V
SENSOR
ENG OIL PRESSURE
ATM PRESSURE
ENG OIL PRESSURE
SENSOR COMMON
SENSOR COMMON
INLET MANF PRESSURE
L45
C413-YL-18
M936-BR-18
893-GN-18
892-BR-18
308-YL
A768-BU
615-YL
E707-GN-18
E708-PK-18
C414-BU-18
C415-WH-18
411-PK-18
E997-YL-18
410-WH-18
P967-PU-18
M947-OR-18
L972-BU-18
A755-PK-18
M944-BU-18
M945-BR-18
M942-WH-18
M943-YL-18
586-BR-18
M961-WH-18
M959-PK-18
M958-OR-18
M955-BR-18
M956-GN-18
A756-BU-18
A757-GY-18
A758-BR-18
E998-BR-18
SENSOR
+5V
SENSOR
COOLANT TEMP
COOLANT TEMP
SENSOR COMMON
+5V
SENSOR
FUEL TEMP
FUEL TEMP
INLET AIR TEMP
INLET AIR TEMP
SENSOR COMMON
+5V
SENSOR COMMON
+5V
308-YL
L45
L46
1
131-RD-14
131-RD-14
130-RD-14
130-RD-14
B
131-RD-14
131-RD-14
151-GN-18
235-BK-14
235-BK-14
235-BK-14
235-BK-14
235-BK-14
K943-OR-18
K944-YL-18
K946-OR-18
K947-YL-18
P964-GY-18
P965-OR-18
E997-BR
K909-BU
P944-GY
H807-YL-18
200-BK-14
M937-GN-18
M938-GY-18
K924-YL
P946-BR
M935-BU-18
K949-OR-18
K952-BR-18
K950-YL-18
200-BK-18
200-BK-14
H807-YL-18
P944-GY
M938-GY-18
M937-GN-18
K924-YL
G426-WH-18
C472-GN-18
H447-YL-18
H442-YL-18
H446-PK-18
130-RD-14
130-RD-14
131-RD-14
131-RD-14
131-RD-14
235-BK-14
235-BK-14
235-BK-14
235-BK-14
235-BK-14
H443-BR-18
L48
L51
K950-YL-18
K952-BR-18
K949-OR-18
K947-YL-18
K946-OR-18
K944-YL-18
K943-OR-18
P944-GY
K924-YL
P946-BR
H807-YL-18
151-GN-18
P964-GY-18
P965-OR-18
E997-BR
K909-BU
M935-BU-18
200-BK-18
200-BK-18
P944-GY
200-BK-18
P944-GY
P944-GY
K952-BR-18
E998-YL-18
E789-PU-18
L982-PK-18
H716-WH-18
200-BK-14
P959-GN-18
K924-YL
K952-BR-18
H807-YL-18
E789-PU-18
200-BK-18
E790-PK-18
B
5
4
1
2
3
X
L51
M937-GN-18
M938-GY-18
L52
L46
L43
L47
M957-GY-18
M964-BR-18
M951-WH-18
M952-YL-18
M965-GN-18
M949-PK-18
M962-YL-18
M950-PU-18
M953-BU-18
M948-BR-18
P966-PK-18
M954-BU-18
M960-PU-18
147-PU-18
607-PK
M963-BU-18
L43
L46
103-RD-18
150-RD-18
L48
ATCH CWTW
L52
200-BK-18
200-BK
200-BK
200-BK
AC
(NOTE G)
114-0421
REMOVAL SW
D
200-BK
200-BK-18
200-BK-18
200-BK-14
200-BK-14
200-BK-10
200-BK-14
200-BK-18
200-BK
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK-18
200-BK
200-BK-18
CHASSIS
1
AC
(NOTE G)
2
C
A
A
B
ATCH
147-PU-18
CWTW REMOVAL
CONT SOL
123-2514
147-PU-18
CHASSIS
D
200-BK-18
L982-PK-18
147-PU-18
200-BK-18
L982-PK-18
57
47
23
403-GN-18 412-BU-18
+B
70
COOLANT LEVEL SW
3
5
ALTERNATOR (R TERM)200-BK-18K927-BU-18
6
K952-BR-18 131-RD-14
CAPSULE FILTER PLUGGIGNG SW
HYD OIL TEMP SENDER
FUEL LEVEL SENDER
HYD TEMP RETURN
LOWERING CHECK RET
8630-BU-18
S
C
A
B
F
200-BK
ATCH
REFUELING PUMP
ATCH REFUELING
POWER RELAY
118-GY
524-BU
-
+
123-3929
P
168-RD-10
323-WH-10
P
3T-0376
168-RD-18
168-RD-18
168-RD-18
329-YL-18
329-YL-18
329-YL-18
168-RD-18
7Y-5505
DOME LAMP
6C-9121
ATCHATCH
REFUELING
F
F
200-BK-18
103-RD-18
ATCH
REFUELING
P
111-4871
START RELAY
365-YL-18
200-BK-18
L976-GN-18
365-YL-18
365-YL-18
L976-GN-18
L976-GN-18
L976-GN-18
TTU
PUMP SW(NO)
6T-9442
2
1
T
168-RD-18
1
U
L976-GN-18
168-RD-18
L976-GN-18
OPERATOR STATION
REFUELING
STOP RELAY
111-4871
DIODE
121-1022
PP
323-WH-10
200-BK-10
ATCH
12V SOCKET
121-0987
U
AUTOLUB
2
325-PK-18
STICK
AUTOLUB
PISTON SW
152-9614
AG (NOTE L)
AH (NOTE M)
XZ (NOTE N)
1
2
AG (NOTE L)
AH (NOTE M)
XZ (NOTE N)
L3
L4
L18
K
L5
R (NOTE D)
616-BU
200-BK-18
200-BK-18
K
K
2
4
1
3
R (NOTE D)
200-BK-18
200-BK-18
H442-YL-18
R (NOTE D)
200-BK
616-BU
H441-GN-18
200-BK
BOOM LAMP
153-2521
210-BK
135-BU
BUCKET
PISTON SW
152-9614
325-PK-18
200-BK-18
168-RD-10
200-BK-10
1
P
P
D
200-BK-10
168-RD-10
1
200-BK-18
325-PK-18
D
L56
2
2
AG
365-YL-18
REFUELING
PUMP SW(NC)
9X-4184
103-RD-18
200-BK
135-BU
120-YL
139-OR-18
633-BU-18
615-YL-18
210-BK
615-YL
615-YL
200-BK
616-BU
K
1
R (NOTE D)
D
HORN
7T-0970
D
D
HORN
7T-0969
HORN
7T-0969
322-GY
322-GY
200-BK
200-BK
3
4
322-GY
322-GY
200-BK
200-BK
322-GY
H441-GN-18
H442-YL-18
2
200-BK
103-RD-18
615-YL
200-BK-14
200-BK
200-BK
200-BK-14
200-BK-18
103-RD-18
200-BK
CAB
ATCH
AUTO
LUBRICATION
2
1
D
A
C
B
D
ON(KEY)
GROUND
SIGNAL
PROVISION
D
CHASSIS
LAMP
153-2523
D
1
2
325-PK-18
607-PK
200-BK
ADAD
325-PK-18
PUMP
150-2782
ATCH
REFUELING
LEVEL SW
5C-6108
1
2
GROUND
ON(KEY)
D
D
616-BU
200-BK
322-GY
607-PK
H441-GN-18
H442-YL-18
200-BK
E456-WH-18
140-BU
200-BK
200-BK
SWING
1
3E-7738
2
SOL
SOL
2
1
1
2
B
B
E790-PK-18
K907-BU-18
B
K934-BR-18
M933-PU-18
M933-PU-18
K932-BU-18
BOOM
O.L.W.D
PRESS SENSOR
106-0178
SIGNAL
+B
GND
AN
B
C
A
BRAKE SOL
121-1491
SWING RH
112-5874
SWING LH
112-5874
168-RD-10
200-BK-10
200-BK-18
200-BK
709-OR
L56
SWING
AUTOLUB
PISTON SW
152-9614
FUEL LEVEL
105-9911
SENSOR
D
2
D
1
BK
2
1
YL
E456-WH-18
140-BU
200-BK
200-BK
709-OR
140-BU
200-BK
L5
K934-BR-18
K932-BU-18
E790-PK-18
M933-PU-18
K907-BU-18
200-BK
200-BK-18
200-BK-10
M933-PU-18
200-BK
L54
L52
200-BK
709-OR
168-RD-10
E456-WH-18
200-BK
H442-YL-18
H441-GN-18
140-BU
B
C
A
322-GY
616-BU
607-PK
AN
L53
200-BK
WH-18
WH-18
4
12
3
1
3
2
4
WH-18
WH-18
3E-5181
2
1
2
1
X
X
K952-BR-18
K947-YL-18
H807-YL-18
P945-OR-18
AS
EXTEND
2
1
1
2
EXTEND
EXTEND
1
2
1
2
X
X
K952-BR-18
K944-YL-18
E789-PU-18
K930-GN-18
X
X
E789-PU-18
K952-BR-18
K931-GN-18
K950-YL-18
BOOM SOL
112-5874
ANTI DRIFT
SOL STICK
147-6776
TRAVEL LH
SOL FRONT
112-5874
TRAVEL RH
SOL FRONT
112-5874
BUCKET SOL
112-5874
STICK SOL
112-5874
200-BK-18
H443-BR-18
P969-BR-18
495-GN-18
L52
L53
ATT SOL
EXTEND
1
2
E789-PU-18
P957-BR-18
112-5874
X
E789-PU-18
P957-BR-18
P944-GY
E789-PU-18
E789-PU-18
K950-YL-18
K931-GN-18
K952-BR-18
H807-YL-18
K947-YL-18
K944-YL-18
K952-BR-18
K952-BR-18
K930-GN-18
SYSTEM PRESS
SOL UP-F
147-6776
SYSTEM PRESS
SOL UP-R
147-6776
ATCH
SOL STICK
111-9916
2
1
X
H807-YL-18
P949-PU-18
1
2
X
1
2
B
P950-YL-18
H807-YL-18
P943-GN-18
M933-PU-18
K924-YLM933-PU-18
P943-GN-18
P945-OR-18
P944-GY
K952-BR-18
H807-YL-18
P950-YL-18
H807-YL-18
P949-PU-18
E790-PK-18
P946-BR
K924-YL
M935-BU-18
200-BK-18
K952-BR-18
H807-YL-18
P946-BR
K927-BU-18
P958-PK-18
P955-BU-18
H807-YL-18
F853-BR-18
ATCH
SOL BOOM
111-9916
1
2
D
P944-GY
K952-BR-18
LOWERING CHECK
LOWERING CHECK
K927-BU-18
K949-OR-18
K952-BR-18
K929-GN-18
K928-GN-18
K946-OR-18
K943-OR-18
K952-BR-18
K952-BR-18
1
X
2
1
2
X
X
SOL
SOL
HYD LOCK
121-1491
PS PRESS
111-9916
X
2
1
X
X
1
2
1
2
TRAVEL RH
SOL REAR
112-5874
STICK SOL
RETRACT
112-5874
TRAVEL LH
SOL REAR
112-5874
X
X
1
2
1
2
X
X
1
2
2
1
X
BOOM SOL
RETRACT
112-5874
BUCKET SOL
RETRACT
112-5874
ATT SOL
RETRACT
112-5874
ANTI DRIFT
SOL BOOM
147-6776
H807-YL-18
K927-BU-18
K949-OR-18
K946-OR-18
K952-BR-18
K943-OR-18
K952-BR-18
K952-BR-18
P946-BR
K927-BU-18
P958-PK-18
K927-BU-18
K929-GN-18
K928-GN-18
2
1
121-1491
SHIFT SOL
1
2
L52
L53
BYPASS SOL
147-6776
H807-YL-18
P955-BU-18
NEUTRAL FLOW
TRAVEL SPEED
OIL FILTER
RESET SW
HYD OIL
LEVEL SW
111-4760
HYD OIL
146-7880
2
1
2
AE
AE
1
TEMP SENDER
102-2240
HYD OIL
FILTER SW
143-7966
HYD OIL
HYD OIL
FILTER SW
143-8037
GND
+B
B
C
AE
B
A
C
+B
4
1
2
4
AE
3
AE
SIGNAL
SIGNAL
SIGNAL
SIGNAL
GROUND
GROUND
SIGNAL
VS
A
B
C
AT
D
L982-PK-18
200-BK-18
4
V
D
306-GN
3
1
2
3
4
1
4
WH-18
WH-18
103-RD-18
103-RD-18
491-PK-18
P969-BR-18
200-BK-18
496-WH-18
103-RD-18
E996-WH-18
103-RD-18
200-BK-18
200-BK-18
E455-BR-18
E455-BR-18
E455-BR-18
E455-BR-18
FILTER SW
143-8037
2
3
GROUND
SIGNAL
1
2
2
WH-18 200-BK-18
P968-OR-18
103-RD-18
+B
1
WH-18
3
K927-BU-18
K952-BR-18
M935-BU-18
K924-YL
F853-BR-18
E790-PK-18
200-BK-18
H446-PK-18
150-RD-18
H447-YL-18
2
508-PU-18
BK
M933-PU-18
P943-GN-18
200-BK-18
K929-GN-18
K928-GN-18
K943-OR-18
K944-YL-18
K946-OR-18
K947-YL-18
K931-GN-18
K930-GN-18
K949-OR-18
K952-BR-18
K952-BR-18
K952-BR-18
K952-BR-18
P958-PK-18
P950-YL-18
P949-PU-18
K927-BU-18
K927-BU-18
K927-BU-18
K927-BU-18
P945-OR-18
P955-BU-18
P957-BR-18
H807-YL-18
H807-YL-18
H807-YL-18
H807-YL-18
H807-YL-18
E789-PU-18
E789-PU-18
E789-PU-18
E789-PU-18
F853-BR-18
M935-BU-18
E790-PK-18
K952-BR-18
K952-BR-18
K950-YL-18
PROXIMITY SW 2
K952-BR-18
H807-YL-18
K952-BR-18
K952-BR-18
K952-BR-18
E790-PK-18
F
11
GG (NOTE B)
CCBB
RD-00
RD-00
AA
NEG
RD-00
POS
FF (NOTE B)
POS
NEG
NEG
POS
RD-00
BATTERY
9X-9731
EE (NOTE B)
BATTERY
9X-9731
(NOTE B)
ATCH
POS
RD-00
BK-00
NEG
412-BU-18
200-BK
506-PU-18
514-PU
310-PU-18
ALTERNATOR
132-2156
B
MOTOR
506-PU-18
B
2
1
B
B
200-BK-18
412-BU-18
200-BK-18
200-BK-18
310-PU-18
200-BK
514-PU
B
200-BK-18
2
B
1
A
430-BU-18
430-BU-18
12
I
109-9330
ATCH
AIR CLEANER SW
START AID
3E-6332
COOLANT
LEVEL SW
109-9436
SOL
A
A/C
CONDENSOR
166-5816
H
MOTOR
R
C
B+
C
ALT
C
B-
200-BK-4
403-GN
109-RD-4
7T-8890
STARTER
109-RD-4
200-BK-4
403-GN
101-RD-4
304-WH-8
GS
B
MOTOR
MTRBAT
B
304-WH-8
RD-00
RD-00
101-RD-4
GROUND STRAP
MOTOR
6V-5539
141-9676
COMPRESSOR GP
REFRIGERANT
AA
ENG OIL
LEVEL SW
111-4759
LOW PRESS SW
114-5333
WASHER
EE(NOTE B)
L50
L49
C
CHASSIS
PICKUP
6V-2455
1
C
ENG SPEED
109-RD-4
101-RD-4
304-WH-8
403-GN-18
L49
2
6
5
8
3
1
B
4
C
B
1
5
10
11
3
6
C
C
200-BK-14
521-YL-18
C468-BU-18
M953-BU-18
788-YL-18
F717-YL-18
F718-BU-18
893-GN-18
892-BR-18
F889-WH-18
308-YL
NOTE A
CONN 5
CONN 4
CONN 3
149-4993
2
C
1
C
1
521-YL-18
513-OR-18
513-OR-18
2
C
1
C468-BU-18
200-BK-18
200-BK-18
G
1
L50
788-YL-18
M953-BU-18
6
5
GND
+B
24
9
3
37
DECEL
ACCEL
15
THROTTLE
200-BK-14
200-BK-18
200-BK-14
CAT DATA LINK (-)
CAT DATA LINK (+)
F
200-BK-18
C
WH-18
BK-18
OR
BK
WH
OR
C
B
A
C
WH
BK
GN
OR
YL
A
B
C
A
B
F732-PK
999-WH
N944-PU
N944-PU
996-GN
996-GN
A745-WH
N941-YL
N940-BU
GN
YL
OR
C
B
A
GN
YL
OR
YL
GN
A
B
C
B
C
A746-PK
A747-GY
994-GY
N941-YL
N941-YL
N941-YL
N940-BU
N940-BU
4
12
8
2
7
9
E720-GN-18
317-YL-18
998-BR-18
E793-BU-18
E794-YL-18
130-RD-14
NOTE A
WH
BK
OR
C
B
A
WH
BK
OR
WH
C
A
B
C
995-BU
C967-BU
A751-YL
N941-YL
N941-YL
N940-BU
N940-BU
OR
A
N940-BU
BKN941-YL
B
999-WH
F732-PK
N944-PU
996-GN
994-GY
995-BU
A745-WH
A746-PK
A747-GY
C967-BU
A751-YL
6
4
1
2
3
5
A701-GY
A706-GY
A702-PU
A703-BR
A704-GN
A705-BU
N940-BU
8
10
12
11
9
7
F701-BR
E799-BR
F700-BU
L984-OR
L983-WH
L985-YL
N941-YL
ORN940-BU
A
29
40
25
7
1
4
8
2
ETHER SW
ETHER SOL
SENSOR COM
UNSWICHED POWER
10
11
13
12
16
18
17
14
ENG
ENG CONT
115-3055
USER DEFN SHUTDOWN
ATA DATA LINK (-)
ATA DATA LINK (+)
20
21
22
23
26
27
28
30
31
32
34
33
36
39
38
35
19
E
4
2
39
10
37
29
+V ENG SP/TMG
+V ENG SP/TMG
1
14
23
20
8
15
3
9
FUEL TEMP
INLET AIR TEMP
COOLANT TEMP
ATM PRESSURE
FUEL PRESSURE
ENG SP/TMG
ENG OIL PRESSURE
INLET MANF PRESSURE
ENG SP/TMG COMMON
36
34
11
+5V
22
6
12
18
28
INJECTOR 1
INJECTOR 2
INJECTOR 3
INJECTOR 4
INJECTOR 5
INJECTOR 6
17
27
5
13
7
19
40
16
JAKE SOL DRIVER
JAKE SOL DRIVER
INJECTOR COM 5&6
INJECTOR COM 1&2
INJECTOR COM 3&4
JAKE SOL DRIVER COMMON
SENSOR COMMON 30
D
1
2
2
1
SOL 6
INJECTOR
2
1
1
2
SOL 3 SOL 4
INJECTORINJECTOR INJECTOR
SOL 5
L51
2
1
2
1
SOL 2SOL 1
INJECTORINJECTOR
AF
L46
L43
L47
B
7
6
2
D
3
4
8
1
5
E789-PU-18
E998-YL-18
L982-PK-18
H716-WH-18
200-BK-14
P959-GN-18
200-BK-14
12
11
B
D
8
9
7
6
10
H443-BR-18
G426-WH-18
E996-WH-18
P969-BR-18
168-RD-10
H447-YL-18
H446-PK-18
200-BK
140-BU
709-OR
386-PK
306-GN
L982-PK-18
200-BK-18
H447-YL-18
H446-PK-18
200-BK-18
332-BU-18
E996-WH-18
P968-OR-18
P969-BR-18
P969-BR-18
P969-BR-18
103-RD-18
495-GN-18
496-WH-18
491-PK-18
4
3
A
1
2
D
12
10
11
9
8
H442-YL-18
H441-GN-18
P968-OR-18
495-GN-18
496-WH-18
491-PK-18
E456-WH-18
6
5
2
3
4
A
1
6
5
4
D
140-BU
709-OR
103-RD-18
322-GY
616-BU
150-RD-18
306-GN
332-BU-18
7
386-PK
616-BU
322-GY
H443-BR-18
H441-GN-18
H442-YL-18
E456-WH-18
200-BK-18
168-RD-10
150-RD-18
150-RD-18
E998-YL-18
E789-PU-18
G426-WH-18
C472-GN-18
200-BK-18
200-BK-18
H716-WH-18
P959-GN-18
150-RD-18
150-RD-18
C472-GN-18607-PK
5
24
26
25
32
35
33
31
38
C
2
1
A
7
8
D
607-PK
B
147-PU-18
3
A706-GY
A701-GY
A702-PU
A703-BR
A704-GN
A705-BU
L984-OR
L983-WH
L983-WH
L985-YL
L985-YL
L984-OR
21
C
ECM GND STRAP
6
2
3
4
5
7
8
306-GN
386-PK
ATCH
SUCTION LINE
332-BU-18
103-RD-18
1
AED
103-RD-18
103-RD-18
P969-BR-18
P968-OR-18
200-BK-18
491-PK-18
496-WH-18
103-RD-18
E996-WH-18
H447-YL-18
H446-PK-18
150-RD-18
200-BK
200-BK-18
L53
E456-WH-18
709-OR
P969-BR-18
168-RD-10
495-GN-18
616-BU
322-GY
607-PK
H443-BR-18
H441-GN-18
H442-YL-18
140-BU
3E-5181
D
A
C
B
+B
GND
PRESS SENSOR
106-0178
SIGNAL
PUMP
D
C
B
A
D
1
2
GND
+B
SIGNAL
PRESS SENSOR
106-0178
SWING PUMP
SWASH SOL
111-9916
SWING PUMP
A
I
H
G
F
E
D
C
B
A
D
2
1
RADIATOR FAN
SPEED CONT SOL
147-5826
E998-YL-18
E789-PU-18
150-RD-18
150-RD-18
H716-WH-18
P959-GN-18
200-BK-18
200-BK-18
G426-WH-18
C472-GN-18
103-RD-18
103-RD-18
103-RD-18
SHUTOFF LIMIT SW
P969-BR-18
496-WH-18
491-PK-18
200-BK-18
P968-OR-18
200-BK-18
L48
200-BK-18
E996-WH-18
103-RD-18
103-RD-18
200-BK-18
200-BK-18
200-BK-18
NOTE B: USE WITH COLD WEATHER.
L18
L18
XY
200-BK
NOTE H: USE WITH FRONT WINDOW FIXED CAB.
LOWER
WIPER MOTOR
131-0398
+
S
-
MOTOR
AN
XZ
NOTE M: USE WITH STICK AND BUCKET AUTOLUB OF MASS EX BOOM
AT
TT
SS
RR
PP
AS
NN
MM
LL
JJ
HH
KK
AD
GG
FF
EEB)
CC
BB
AA
CABLE AS.
NOTE L: USE WITH R3.6V STICK AND BUCKET AUTOLUB OF REACH BOOM
AH
AG
-
+
MOTOR
CONVERTER
131-0327
GND
24V BAT IN MEM
200-BK
615-YL
24V SW. IN
LIGHT OUT (DC 12V)
615-YL
200-BK
12V MEM OUT
GND
615-YL
615-YL
M MF
12V SW. OUT
LIGHT IN (DC 24V)
1
23456789101112 1
607-PK
UPPER WIPER MOTOR
131-0399
CONTROL SW
175-6496
LH JOYSTICK
SWITCH
HAMMER PEDAL
153-8709
SW CMH
STRAIGHT
TRAVEL PEDAL
145-3059
SWITCH
SW TR
SW TL
SW CMH
TRAVEL PEDAL
145-3056
PWM TR
PWM TL
SW CMH
CHASSIS LAMP
153-2523
CONTROL SW
175-6497
ONE TOUCH LOW IDLE (+)
ONE TOUCH LOW IDLE (-)
A
L18
GY
PU
BR
RED
WHITE
ORANGE
YELLOW
PINK
ABBREV COLOR
BLACK
GRAY
PURPLE
BROWN
BK
PK
YL
OR
WH
RD
GN
BU
GREEN
BLUE
RH JOYSTICK
NOTE N: USE WITH R2.8W STICK AND BUCKET AUTOLUB OF REACH BOOM
F MM
CAB LAMP
153-2521
CAB LAMP
153-2521
X
AF
AE
NOTE A: THE FOLLOWING WIRE PAIRS MUST BE TWISTED
AT LEAST 1 TURN PER 25MM.
(892-BR, 893-GN) (E793-BU, E794-YL)
NOTE G: USE WITH CTWT REMOVAL.
G
B
AC
V
NOTE C: THE FOLLOWING WIRE PAIRS MUST BE TWISTED
AT LEAST 1 TURN PER 25MM.
(E708-PK, C413-YL, C414-BU)
FOR A SINGLE SHEET VERSION OF THIS SCHEMATIC
CONTACT DESIGN CONTROL.
UNLESS OTHERWISE SPECIFIED ALL WIRE IS 16 GAUGE.
COMPONENTS ARE SHOWN INSTALLED ON A FULLY
OPERABLE MACHINE WITH THE KEY AND ENGINE OFF.
THIS SCHEMATIC IS FOR THE 365B EXCAVATOR. (143-1645 V02)
WIRE AS.
R
M
K
J
H
F
E
D
C
IDENT PART NO. LOC
HARNESS AS.
Z
S
T
A
NOTE E: NOT NECESSITY FOR ELECTRIC OPENABLE WINDSHIELD
U
NOTE D: USE WITH MASS BOOM.
P
162-9850
170-6886
170-6901
167-3628
163-6715
149-5064
163-6714
163-6713
167-3586
163-6650
163-6649
149-5058
149-5057
7Y-3935
163-6712
132-1827
149-5007
8V-0622
149-5006
116-0081
8V-0622
149-4989
163-6760
163-6784
149-4987
145-0176
149-4986
170-9468
167-3602
149-5025
121-1044
149-5004
117-7028
149-5003
184-7583
185-0575
162-8887
136-2561
170-6897
175-1248
177-6632
136-4731
116-0096
170-9470
116-0098
149-5017
H-3
A-6
A-3 (NOTE N)
B-10
I-8
I-8
I-8
I-8
B-7
H-9
H-9
I-8
I-9
I-8
H-9
A-4
I-11 (NOTE B)
I-11 (NOTE B)
I-12 (NOTE B)
I-11
I-12
I-12
A-3 (NOTE M)
A-3 (NOTE L)
B-9
D-12
A-10
G-9
D-7
B-10(NOTE G)
A-11
A-4 (NOTE D)
E-1
A-4
H-4
F-4
B-5
C-5
C-12
F-12
I-7
H-3
A-2
C-5
A-3
A-3
DESCRIPTIONSYMBOL
CONNECTOR
ELECTRICAL CONNECTION
TO MACHINE STRUCTURE
INTERNAL ELECTRICAL
CONNECTION TO SURFACE
OF COMPONENT
BLADE, SPADE, RING,
OR SCREW TERMINAL
CIRCUIT CONNECTED
CIRCUIT NOT CONNECTED
ATCH WIRE, CABLE,
COMPONENT
L#
CIRCUIT GROUPING
DESIGNATION
2
7
CONN 1
CONN 2 CONN 6
CONN 8
CONN 7
CONN 9
CONN 10
CONN 10
CONN 11
CONN 11
CONN 21 CONN 22 CONN 23
CONN 24
CONN 40
CONN 39
CONN 38
CONN 37
CONN 36
CONN 35
CONN 34
CONN 41
CONN 53
CONN 55
CONN 54
CONN 52
CONN 31 CONN 32 CONN 33 CONN 42 CONN 43 CONN 44
CONN 51CONN 50
CONN 49
CONN 48
CONN 47CONN 46CONN 45CONN 30
CONN 28
CONN 27
CONN 26
CONN 25
CONN 29
ALL DASHED LINES ARE ATTACHMENTS.
WIRES THAT HAVE BATTERY VOLTAGE
WHEN THE KEY SWITCH IS OFF.
WIRES THAT HAVE BATTERY VOLTAGE
WHEN THE KEY SWITCH IS ON.
STARTING CIRCUIT.
GAUGE CIRCUIT.
VIDS CIRCUIT.
PANEL LAMP CIRCUIT.
TURN SIGNAL AND WIPER/WASHER CIRCUIT.
HEATER AND AIR CONDITIONER CIRCUIT.
GROUND CIRCUIT.
ENGINE CONTROL CIRCUIT.
START AID CIRCUIT.
MACHINE CONTROL CIRCUIT.
